32-Channel SIL-2/SIL-3 Single-Ended Analog/Digital Input …

1 32-Channel SIL-2/SIL-3 single -EndedAnalog/Digital Input Card3026/00-0023026/00-002 32-Channel Single-Ended Analog/Digital Input CardRTP Corp. 1834 SW 2nd Street Pompano Beach, Florida 33069 PHONE (954) 974-5500 FAX (954) 975-9815 INTERNET: EMAIL HIGHLIGHTS 32 Single-Ended Channels Current, Voltage, or Digital Inputs Options Redundant 16-Bit A/D Converters Supports Dual, Triple, and Quad Redundancy I/O Bus Checking Diagnostics Line Supervision Option Available LED Card Health Indicator Hot swappablePRODUCT OVERVIEWThe 32-Channel Scanning single ended analog /DigitalInput Card is TUV approved for SIL-2 and SIL-3 applica-tions. It provides high accuracy, high-level analog mea-surements or digital inputs. A guard band above and be-low the full-scale signal range allows signals exceedingthe specified Input signal range to be detected by soft-ware.

2 The change of any Input channel state initiates thelogging of a time-stamped sequence-of-events (SOE)record with 1 msec resolution. This card is IEC 61131-2qualified and performs comprehensive diagnostic testson all Input channels and backplane communications fordetecting internal faults; any errors detected are reportedto the operating conversion is performed by redundant16-bit switched capacitor successive approximationA/D converters (sign bit + 15-bit magnitude). No fieldadjustments are necessary after initial factory trim. TheA/D converters calibration is continually checked bymonitoring two internal fixed (high and low) card can operate in three different modes: currentinputs, voltage inputs, or digital inputs. When receivingdigital inputs, the 3026/00 can operate in supervised modeor unsupervised mode.

3 Input modes determine which RTPtermination module is required for proper card changes to the card are not used in supervised digital Input mode, the 3026/00-002 can detect line shorts and line 3026/00-002 Analog/Digital Input Card s hot swap-pable design has backplane interface logic to protectthe card from damage, and to prevent control and datasignal degradation on the bus, when plugged into a liveRTP is the Best Technology for Your Investment,Here s Why:The 3000 is a multi-processor architecture that deliversexceptional Performance and ComprehensiveDiagnostics. The results speak for themselves: AReaction Time of 12 msec, true 1 msec SOE (Analogand Digital), an MTBF of greater than 2500 years, anMTTFS of greater than 3000 years, and a PFDavg Compare these numbers to any other Proof Test Diagnostics means it will never benecessary to shut down at the proof test online downloads of logic and configurationchanges do not require a periodic shut down like othersystems.

4 Compare this functionality to any Suite Software: One-time price includes unlimiteduse of Logic Development, Alarm Manager, DataArchive and Historian, and HMI without hardware orsoftware keys. Compare this functionality and priceto all other , a Safety Instrumented System (SIS) shouldalways take the process it protects to a safe state whenit is required to do so, and it should never interfere withthe operation of the process at any time. The 3000does this better than any other Bus self-test functions are performed for all Input data,status and command transfers to and from the analog in-put card. Each transfer is performed twice (all the data bitsin the second transfer are inverted.) Both transfers arethen compared to insure that no errors exist in the datapath between the analog Input card and the processor.

5 I/O Bus slot address and control signal contention tests arealso performed. Any errors are reported in the card s sta-tus acknowledgments: RTP is a registered trademark of RTP Corp. All other product or service names mentioned herein are trademarks of theirrespective owners. Specifications and information are subject to change without notice. Contact RTP s corporate office for the latest information, data, graphics and statements in this document are proprietary intellectual property of RTP Corp. unless otherwise indicated and are to beconsidered RTP Corp. confidential. This intellectual property is made available solely for the direct use of potential or licensed RTP Corp. customers in theirapplication of RTP Corp. products, and any other use or distribution is expressly prohibited. If you have received this publication in error, immediately delete,discard or return all copies to RTP Safety Integrity LevelSIL 2 - AnalogSIL 3 - DigitalNumber of Inputs32 channelsIsolation500V AC/DC channel toRTP systemFull Scale Range: ( mA)Scan Rate1000 scans per secondAccuracy: Full Scale Voltage at +25 C Full Scale Voltage/K temperature coefficient Full Scale Voltage (0 C to +55 C) Full Scale Current at +25 C Full Scale Current/K temperature coeffecientRedundancy support allows the inputs of two, three, orfour cards to be connected in parallel to the same inputdevice.

6 When using redundant configurations, the signalvalidation ( Input voting) function can be used to validatethe inputs received by the node processor. Redundant con-figurations increase system availability and allows the cardto reach a SIL-3 rating. A single front panel LED providesthe health status of the Redundant Input Configuration Full Scale Current maximum (0 C to +55 C)Resolution16 bitsInput Source Impedance: 1 k maximum to meet specificationsMultiplexer Type: Solid-state multiplexersPower Requirements+5V DC @ 400 mA +24V DC @ 100 mAEnvironmental*Standard Operating Temperature Range: 20 C to +60 CStorage Temperature Range: 25 C to +85 CRelative Humidity Range: 10% to 95%, non-condensing*Complies with IEC 61131-2 Termination Cable Included with 3026/00-002 CardTermination Modules**Contact factory for a complete list of all available terminations **Requires additional +24V DC power source^Meets all IEC 61131-2 requirements except standard operating range for digital Input (current sinking)

7 3099/21-002 TerminationModuleBackplaneBusChassisProc essorBridgeRectifierInputSwitchTerminati onCableBridgeRectifierMulti-plexer1 of 32 Input ChannelsShieldLowHighInputSourceTerminat ionCableTerminationCableTerminationCable 3099/21-002 TerminationModuleShieldShieldLowLowHighH ighA/DConverterAmplifierA/DConverterBack planeInterfaceandControlLogicBackplaneBu sChassisProcessorBridgeRectifierInputSwi tchBridgeRectifierMulti-plexer1 of 32 Input ChannelsA/DConverterAmplifierA/DConverte rBackplaneInterfaceandControlLogicBackpl aneBusChassisProcessorBridgeRectifierInp utSwitchBridgeRectifierMulti-plexer1 of 32 Input ChannelsA/DConverterAmplifierA/DConverte rBackplaneInterfaceandControlLogicBackpl aneBusChassisProcessorBridgeRectifierInp utSwitchBridgeRectifierMulti-plexer1 of 32 Input ChannelsA/DConverterAmplifierA/DConverte rBackplaneInterfaceandControlLogiceludoM noitanimreTnoitpircseDeludoMnoitanimreTn oitpircseD200-12/9903tupnIgolanAegatloVh C23-eludoMnoitanimreTelpirT201-12/9903tu pnIgolanAegatloVhC23-eludoMnoitanimreTel gniS700-12/9903tupnIgolanAtnerruChC23-el udoMnoitanimreTelpirT701-12/9903tupnIgol anAtnerruChC23-eludoMnoitanimreTelgniS10 0-12/9903tupnIlatigiDdesivrepuShC23-elud oMnoitanimreTelpirT101-12/9903tupnIlatig iDdesivrepuShC23-noitanimreTelgniS300-12 /9903 CDV42,tupnIlatigiDgnikniShC23-noitanimre TelpirT301-12/9903 CDV42,tupnIlatigiDgnikniShC23-noitanimre TelgniS400-12/9903 CDV84,tupnIlatigiDgnikniShC23-noitanimre TelpirT401-12/9903 CDV84,tupnIlatigiDgnikniShC23-noitanimre TelgniS^**500-12/9903 CAV511,tupnIlatigiDgnikniShC23-noitanimr eTelpirT^**501-12/9903 CAV511.

8 TupnIlatigiDgnikniShC23-noitanimreTelgni S^**600-12/9903 CAV032,tupnIlatigiDgnikniShC23-noitanimr eTelpirT^**601-12/9903 CAV032,tupnIlatigiDgnikniShC23-noitanimr eTelgniS**800-12/9903 CDV511,tupnIlatigiDgnikniShC23-noitanimr eTelpirT**801-12/9903 CDV511,tupnIlatigiDgnikniShC23-noitanimr eTelgniS**900-12/9903 CAV511, **901-12/9903 CAV511, ,tupnIlatigiDgnicruoShC23-noitanimreTelp irT311-12/9903 CDV42,tupnIlatigiDgnicruoShC23-noitanimr eTelgniS410-12/9903 CDV84,tupnIlatigiDgnicruoShC23-noitanimr eTelpirT411-12/9903 CDV84,tupnIlatigiDgnicruoShC23-noitanimr eTelgniS**510-12/9903 CAV511,tupnIlatigiDgnicruoShC23-noitanim reTelpirT**511-12/9903 CAV511,tupnIlatigiDgnicruoShC23-noitanim reTelgniS**610-12/9903 CAV032,tupnIlatigiDgnicruoShC23-noitanim reTelpirT**611-12/9903 CAV032,tupnIlatigiDgnicruoShC23-noitanim reTelgniS**810-12/9903 CDV511,tupnIlatigiDgnicruoShC23-noitanim reTelpirT**811-12/9903 CDV511,tupnIlatigiDgnicruoShC23-noitanim reTelgniS