363 - Food and Agriculture Organization

1 363. Chapter 16. grain crop drying, handling and storage Introduction within the crop, inhibiting air movement and adding Although in many parts of Africa certain crops can be to any possible spoilage problems. The crop must produced throughout the year, the major food crops therefore be clean. such as cereal grains and tubers, including potatoes, One of the most critical physiological factors in are normally seasonal crops. Consequently the food successful grain storage is the moisture content of the produced in one harvest period, which may last for only crop. High moisture content leads to storage problems a few weeks, must be stored for gradual consumption because it encourages fungal and insect problems, until the next harvest, and seed must be held for the respiration and germination.

2 However, moisture next season's crop. content in the growing crop is naturally high and only In addition, in a market that is not controlled, the value starts to decrease as the crop reaches maturity and the of any surplus crop tends to rise during the off-season grains are drying. In their natural state, the seeds would period, provided that it is in a marketable condition. have a period of dormancy and then germinate either Therefore the principal aim of any storage system must when re-wetted by rain or as a result of a naturally be to maintain the crop in prime condition for as long adequate moisture content.

3 As possible. The storage and handling methods should Another major factor influencing spoilage is minimize losses, but must also be appropriate in relation temperature. Grains are biologically active and respire to other factors, such as economies of scale, labour cost during storage. One of the products of respiration is heat, and availability, building costs and machinery cost. and reducing the temperature of the crop can help to diminish the rate of respiration, thereby lengthening the grain drying storage life by lessening the possibility of germination. The handling and storage of grains will be discussed in Another major temperature effect is on the activity of an orderly sequence.

4 First we discuss the requirements insect and fungal problems. With lower temperatures, for safe storage, including the principles involved in the metabolic rate of insects and fungi decreases and both natural and artificial drying, followed by drying consequently so does the activity causing spoilage. methods suitable for the small grower, as well as for the A damp or warm spot in grain will increase the rate larger scale operations of cooperatives and commercial of respiration. In addition to heat, another product of farms. Finally, various types of storage structures and respiration is moisture. The heat and moisture from systems, from family size up to commercial units, are such a hot spot' can spread by convection, encouraging discussed, together with management suggestions for moulds and bacteria, which in turn respire and give off preventing damage during the storage period.

5 More heat and moisture. It therefore becomes a self- generating process. Insect activity also increases with a Properties of grains rise in temperature. Cereal grains are edible seeds and, as such, would These spoilage mechanisms can also affect the eventually be released from the plant when fully viability of grain required for seed or malting, where the mature. Grains can be divided into three groups; cereals inability to germinate would render it unmarketable. (maize, wheat, millet, rice, etc.), pulses (beans, peas, Figure shows how the relationship between cowpeas, etc.), and oil seeds (soyabeans, sunflower, moisture content and temperature affects the storability linseed, etc.)

6 Of crops. It can be seen that the moisture content of grain must be reduced at higher temperatures. Requirements for safe storage Crops left standing un-harvested start to show Moisture content diminishing quantitative and qualitative returns The moisture content of a crop is normally given on a through shatter losses and attacks by insects, mould, wet basis' (wb) and is calculated as follows (%mcwb): birds and rodents. It is therefore important to complete harvesting as soon as possible. In addition, it is necessary Weight of moisture to remove dust and contaminants, which can include 100. Weight of wet sample insects, and vegetable material, such as bits of straw and chaff and weed seeds.

7 These will fill up pore spaces 364 Rural structures in the tropics: design and development 40. be dried for a period of time and then re-weighed. The scales should preferably be electronic unless a large enough sample is used, in which case good mechanical 30. Safe scales can be used. Insect The rapid-oven method is one of a number of faster Temperature C. heating Fall in laboratory methods. These methods range from simple, 20 germination Fungal inexpensive pieces of equipment to highly sophisticated A. heating and expensive instruments. A typical simple method C consists of shining an infrared lamp on a balance pan 10.

8 B containing a ground sample of approximately 5 grams. The sample is exposed to the intense heat of the lamp for a predetermined period and the loss in weight is shown Weight of moisture on a scale calibrated for percentage moisture content. 0. 10 15 10020 25. Weight of wet sample Moisture (percent) The salt-jar method is a simple field method for determining whether maize is dry enough for storage in Figure Effects in storage at different temperatures bags. A teaspoon full of dry non-iodized salt is placed Weightcontent and moisture of moisture in a thoroughly dry jar (or bottle) with a tight cover. 100.

9 Weight of wet sample The salt should not stick to the sides of the jar when it is rolled. Then a cob of maize is shelled, the kernels Occasionally dry basis' (db) moisture content is placed in the jar and the cover sealed tightly. The jar is 20 100 and it is important to know which has been used. given then shaken and rolled gently for 2 3 minutes. If the For= example, 20% on wet basis if 100 kg(wb) or grain is dried and of moist salt does not lump or adhere to the sides of the jar, the 100. loses 20 kg of water, the moisture content is: moisture is usually below 15 percent. Moisture meters measure one or more electrical properties of the grain that are closely related to 20 100.

10 = 20% on wet basis (wb) or moisture content. Although acetylene and hair 100 hygrometer measurement techniques have been used in the past, electrical moisture meters are now the most 20 100. = 25% on dry basis (db) commonly used type of moisture meter. Developments 80 in electronics have led to the manufacture of cheap and easy-to-use electronic meters that are also quite grain will normally be harvested at a moisture accurate. These are sold under different brand names. 20 100. content of =18 25 25% onpercent (wb), dry basis (db) although it can be 80. substantially higher or lower depending on many Relative humidity factors (such as the stage of maturity, season, weather Relative humidity (RH) as a measure of air moisture pattern and drying facilities).