Transcription of CONVECTION STEAMER WITH KETTLE AND GAS FIRED …
1 CONVECTION STEAMER with KETTLE AND GASFIRED STEAM BOILER2/9/05 ModelDescriptionGCX-2-66 pan STEAMER with 6 gallon KETTLE and200,000 btu pan STEAMER with 10 gallon KETTLE and200,000 btu pan STEAMER with 6 gallon KETTLE and250,000 btu pan STEAMER with 10 gallon KETTLE and250,000 btu : CONVECTION STEAMER complete with 6 or 10 gallon KETTLE on amodular gas FIRED steam boiler base, with stainless steel type304 exterior and #4 finish, deck mounted faucet valve, swingnozzle and integral sink with common CONVECTION STEAMER shall have doors with removableinner liner of stainless steel, full perimeter gasket seal, outershell of one piece all welded stainless steel, positive lock andseal mechanism and a stainless steel drip trough connectedto drain to collect condensate when doors are opened. Eachcooking chamber shall be constructed of all welded type 316stainless steel, fully insulated and provided with removablestainless steel pan supports.
2 The cooking chamber formodels GCX-2 shall be "W x "H (352mm x 276mm x 504mm) and the cookingchamber for models GCX-10 shall be "W x "Hx (352mm x 441mm x 504mm). STEAMER controls shall be accessible through a fullyremovable side panel and each compartment shall include a60 minute mechanical timer with ready and cooking pilot lightand shall interrupt steam flow to the chamber when thecompartment door is opened during cooking cycle and shallbe reactivated when the door is closed. An audible signalwhich will sound at the end of the cooking cabinet base with gas boiler and controls shall beprovided with full perimeter painted angle frame, reinforcedkettle and boiler mountings, hinged doors with magnetic latchand 6"(152mm) stainless steel legs fitted with adjustablebullet feet on the front and adjustable flanged feet on the rearfor securing unit to the floor.
3 Boiler controls shall includeautomatic water level control, pressure gauge, water gaugeglass, operating pressure control, safety high-limit pressurecontrol, safety relief valve and cathodic protector. The boilershall be ASME code stamped and National Board Capacity Per CompartmentModelPan Depth1"2-1/2"4"6"GCX-26321 GCX-1010532 OPERATION SHALL BE BY:Gas FIRED steam boiler operating at 9-11 psi. The controlsshall be equipped for operation on 115 VAC,1 phase, 50 gas gasOPTIONAL ITEMS AT EXTRA COST:G250,000 BTU (GCX-2 models)G300,000 BTUG208-240 VAC operation(specify voltage)GElectronic ignitionGCSD-1 GStainless steel rear panelGStainless steel frameGSplit water lineGCorrectional packageGAdjustable front flanged feetGLoad compensating timersACCESSORIES:GSteam take off kitGDe-liming kit (DPA-1)not available with CSD-1 GWater in Y strainerGSpray and rinse assemblyShall be a SteamCan Model ,Tel: (416) 570-7226 Fax: (866) 273-2095 Email.
4 SteamCanEquipment CONNECTIONSFAILURE OR MALFUNCTION OF THIS APPLIANCE DUE TO POOR WATER QUALITY IS NOT COVERED UNDER QUALITY STATEMENTGCX-2-6 GCX-2-10 MODELGAS SUPPLYBTU/HOURkW/HOURWATER COLUMN PRESSURESPROPANENATURALGCX-10-10 GCX-10-6 ABC As continued product improvement is a policy of SteamCan specifications are subject to change without Ltd.
