ELECTRICAL EQUIPMENT FLUID TESTING RESULTS ... - …

1 DISCLAIMER: All TESTING was provided by SD myers , Inc. analytical lab with all data being provided to powerdb for the convenience of S. D. myers , Inc. customers using powerdb . SD myers , Inc. shall not be liable for any errors in data or format of data after provided to powerdb . For comprehensive test data, SD myers , Inc. Rainbow Report, or to verify any information provided through this report, please visit or call SD myers , Inc. at TC# ELECTRICAL EQUIPMENT FLUID TESTING RESULTS ( TESTING provided by SD myers , Inc.)1 INSULATION FLUIDL ocationOwnerOtherAUTOMATEDINSULATION FLUIDCitySubstationPositionJob #PageUnit PlantExample OwnerPlantNOTE: * AFTER A TEST RESULT INDICATES THAT THIS TEST WAS PERFORMED OTHER THAN SD myers TO ABBREVIATIONS.

2 AC -- ACCEPTABLE QU -- QUESTIONABLE UN -- UNACCEPTABLE RS -- RESAMPLEADDITIONAL EQUIPMENTHose Length (feet)Service OnlinePower AvailableLTC CompartmentConservator TankBushing LocationBreather High VoltageLow VoltageWeight (lbs)Manufacture DateManufacturerSerial RatingEquipment TypeImpedance %Phase/CycleLiquid TypeGallonsOther AccessTransformer ClassNAMEPLATE DATAR adiatorsFansWater CooledOil PumpsTop FPV (inch)Bottom FPV (inch)Insulation TypeTOP TEMPSAMPLE TEMPP/VPAINTLEVELVISUAL INSPECTION LEAKSDATEFIELD SERVICESERVICEDATEA dditional InformationReason Not TestedIFTDIEL 877 DIEL 1816 SERVICEVISUALACIDLIQUID SCREEN TEST DATAGAPCOLORSP. DATELIQUID POWER FACTOR25 C100 CDATEINHIBITOR CONTENTPCT. BY WEIGHTDATEThis test was not run on this test was not run on this : * AFTER A TEST RESULT INDICATES THAT THIS TEST WAS PERFORMED BY AN OUTSIDE TO ABBREVIATIONS: AC -- ACCEPTABLE QU -- QUESTIONABLE UN -- UNACCEPTABLEDISCLAIMER: All TESTING was provided by S.

3 D. myers , Inc. analytical lab with all data being provided to powerdb for the convenience of S. D. myers , Inc. customers using powerdb . S. D. myers , Inc. shall not be liable for any errors in data or format of data after provided to powerdb . For comprehensive test data, S. D. myers , Inc. Rainbow Report, or to verify any information provided through this report, please visit or call S. D. myers , Inc. at Low OwnerOwnerTC# ELECTRICAL EQUIPMENT FLUID TESTING RESULTS ( TESTING provided by SD myers , Inc.)AVG TEMPPCT. TEST MOISTURE CONTENT EXPRESSED IN ANALYSIS EXPRESSED IN PPBDATECARBON DIOXIDECARBON MONOXIDENITROGENOXYGENHYDROGENMETHANEETH YLENEACETYLENEETHANEGAS-IN-OIL ANALYSIS GAS CHROMATOGRAPHY EXPRESSED IN PPMDATETOTAL GASTOTAL METALS-IN-OIL EXPRESSED IN PPMCOPPERDATEPCB CONTENT EXPRESSED IN PPM12601254 TOTAL1242 OTHERDATEThis test was not run on this test was not run on this test was not run on this test was not run on this test was not run on this : * AFTER A TEST RESULT INDICATES THAT THIS TEST WAS PERFORMED BY AN OUTSIDE TO ABBREVIATIONS: AC -- ACCEPTABLE QU -- QUESTIONABLE UN -- UNACCEPTABLEDISCLAIMER: All TESTING was provided by S.

4 D. myers , Inc. analytical lab with all data being provided to powerdb for the convenience of S. D. myers , Inc. customers using powerdb . S. D. myers , Inc. shall not be liable for any errors in data or format of data after provided to powerdb . For comprehensive test data, S. D. myers , Inc. Rainbow Report, or to verify any information provided through this report, please visit or call S. D. myers , Inc. at Low OwnerOwnerTC# ELECTRICAL EQUIPMENT FLUID TESTING RESULTS ( TESTING provided by SD myers , Inc.)RECAP RECOMMENDATIONSCOMMENTS:DEFICIENCIES:Equ ipment Type:Model:Bank & Phase: Breathing: Cooling: FLUID Volume: FLUID Type: DISSOLVED GAS ANALYSISPage:4 Location:Year of Mfg.:kV Rating:AUTOMATEDP osition:INSULATION FLUIDS ubstation:INSULATION FLUIDPO Number:Report Number:Job Number:Serial Number:Manufacturer: Report Date:Laboratory No.

5 :Container No.:Temperature:Methane (ppm):Ethane (ppm):Ethylene (ppm):Acetylene (ppm):Carbon Monoxide (ppm):Carbon Dioxide (ppm):Nitrogen (ppm):Oxygen (ppm):TDCG Rate (ppm/day):TDCG (gallons):TDHHG (ppm):ETCG (% in blanket):C2H2 / C2H4:C2H2 / CH4:C2H6 / C2H2:C2H4 / C2H6:CO2 / CO:Rodgers Ratios (4):Heat Index:Doernenburg Ratios:CO2 / CO:Dissolved Gas DiagnosticsRodgers Ratios (3): 3123 Fite Circle Sacrmento, CA 95827 (916) 361-71771000 Riverbend Blvd: Suite O St. Rose, LA 70087 (604) 468-88373098 Happy Valley Road Sun Prairie, WI 53590 (608) 825-2022204 Gale Lane Kennett Square, PA 19348 (610) 925-0688 REVISED 9/23/2010000000 Sample Date:Hydrogen (ppm):Total (ppm):TDCG (ppm):CH4 / H2:Key Gas Method: Operating Procedure:Sampling Interval:Condition:TDCG Level (ppm):TDCG Rate (ppm/day):IEEE Std.

6 - 1991 Comments:DISSOLVED GAS ANALYSISPage:5(C2H4)(C2H2)CARBON DIOXIDENITROGENAVERAGE (SOLID LINES) ANDHISTORICAL DATA WITHCOMBUSTIBLE GAS(C0)2-SIGMA (DOTTED LINES)OXYGEN(N2)(C02)* ACETYLENE* ETHANE(CH4) 3123 Fite Circle Sacrmento, CA 95827 (916) 361-71771000 Riverbend Blvd: Suite O St. Rose, LA 70087 (604) 468-88373098 Happy Valley Road Sun Prairie, WI 53590 (608) 825-2022204 Gale Lane Kennett Square, PA 19348 (610) 925-0688 REVISED 9/23/2010* METHANE* ETHYLENE(H2)(C2H6)AVERAGE (SOLID LINES) AND2-SIGMA (DOTTED LINES)HISTORICAL DATA WITH* HYDROGEN(O2)* CARBON MONOXIDE* COMBUSTIBLE GASTOTAL57450, REVISED 7/7/2010 COPYRIGHT 2002-2014 powerdb , BY:TEST EQUIPMENT USED:Default AdministratorOTS60PB EDITIONOTS SER.

7 NO. PASS/FAIL LIMITOIL TYPEOIL TEST - COMPACT6 INSULATION FLUID10/13/2014 INSULATION FLUIDPLANTAUTOMATED FExample PlantExample OwnerOWNER%ASSET IDHUMIDITYAMBIENT # mmPASS LIMITNO. TESTSBREAKDOWN VOLTAGE (kV)FREQ Hz34 RESULTss/xSTD DEVSAMPLETEST STANDARDTEMPF5126 AVG61 SAMPLE NOTES1 COMMENTS:DEFICIENCIES:Phone 317 888 7288 Fax 317 888 Commerce Square Drive Indianapolis, IN 46237 USADISSOLVED GAS ANALYSISWEIDMANN DIAGNOSTIC SOLUTIONS ACCOUNT INSULATION FLUID FLUID POSITION ORDER #KVAKV % IMP. (% Z) CONTAINER RECEIVED REPORTED CUSTOMER ID #TANK BREATHING GALLONSSUBSTATIONP. O. #ATTNCONTROL # INSULATION FLUIDPAGEJOB #PROJECT ID 7 LOCATIONAUTOMATEDD-877D-924D-924D-1298 OIL TEMP (C)METHANE (CH4)ETHANE (C2H6)ETHYLENE (C2H4)ACETYLENE (C2H2)CARBON MONOXIDE (CO)CARBON DIOXIDE (CO2)NITROGEN (N2)OXYGEN (O2)TOTAL DISSOLVED GASTOTAL DISSOLVED COMBUSTIBLE GAS(mg KOH/g)(RELATIVE)(dynes/cm)(ppm)(RELATIVE )(RELATIVE)(kV)(%)(%)(RELATIVE)MOISTURE IN OILINTERFACIAL TENSIONACID NUMBERVISUAL EXAMCOLOR NUMBERSEDIMENT EXAMDIELECTRIC BREAKDOWNPOWER FACTOR-25 POWER FACTOR-100 CSPECIFIC GRAVITYMOISTURE IN OILINTERFACIAL TENSIONACID NUMBERCOLOR NUMBER AND VISUALDIELECTRIC BREAKDOWN D-877 DGA TDCG RATE INTERPERATIVE METHODORDER NUMBERREPORT UNITS.

8 PPMHYDROGEN (H2)LAB CONTROL NUMBERDATE SAMPLEDASTM D-3612 DGA KEY GAS / INTERPRETIVE METHODD-1533 BDISSOLVED GAS ANALYSIS D-1816(kV mm-C)DIELECTRIC BREAKDOWN 1 mmPOWER FACTOR @ 100 CDIELECTRIC BREAKDOWN D-1816 POWER FACTOR @ 25 CDGA IEEE/ANSI ( )IEEE ( )OXIDATION INHIBITOREQUIVALENT TCG PERCENTD-974D-1500(Most Recent Sample)(wt. %):D-1298 PASSIVATOR(ppm)WDSOXIDATION INHIBITORD-1524D-1816(kV mm-C)DIELECTRIC BREAKDOWN 2 mmD-971D-1524(Two most recent samples)DGA CELLULOSE (PAPER) INSULATIONWDS DGA CONDITION CODEWDS RECOMMENDED ACTIONOIL SCREENDIAGNOSTICS(O2)* METHANE* ETHYLENE(H2)(C2H6)(C2H4)(C2H2)CARBON DIOXIDENITROGENAVERAGE (SOLID LINES) ANDHISTORICAL DATA WITH* COMBUSTIBLE GASCOMBUSTIBLE GAS(C0)2-SIGMA (DOTTED LINES)TOTALOXYGEN(N2)(C02)* CARBON MONOXIDE* ACETYLENE* ETHANE(CH4)

9 * HYDROGENSUBSTATIONDISSOLVED GAS ANALYSISINSULATION FLUID8 USER INSULATION FLUIDPOSITIONSERIAL JOB #PAGE57952, PAGE 2 OF 3, REVISED 2/7/2014 COPYRIGHT 2002-2014 powerdb , GAS ANALYSISINSULATION FLUID9 USER INSULATION FLUIDPOSITIONSERIAL JOB #PAGE57952, PAGE 3 OF 3, REVISED 2/7/2014 COPYRIGHT 2002-2014 powerdb , :DEFICIENCIES:OTS OIL TEST10 INSULATION FLUID10/13/2014 INSULATION FLUIDPLANTAUTOMATED FExample PlantExample OwnerOWNER% ASSET IDHUMIDITYAMBIENT #DATEPAGEPOSITIONSUBSTATION57390, REVISED 7/31/2012 COPYRIGHT 2002-2014 powerdb , BY:TEST EQUIPMENT USED:Default AdministratorINSTRUMENT TYPE:11 TEST ID:BREAKDOWN VOLTAGE (kV)MAX VOLTAGE:RESULT ID:DATE:TIME:NO. OF RESULTS :SOFTWARE:STD LIB:ELECTRODE TYPE:MEAN BREAKDOWN:STIRRER TYPE:STD DEVIATION:VOLTAGE RISE:OIL TYPE:mmDISPERSION:RANGE:VALIDATION %:TRIP SETTING:VALIDATION VALUE:RESULT:MACHINE SERIAL NO:OIL TEMPERATURE:V/skVkVkVkVkV%ELECTRODE GAP:NOTES:TEST FREQUENCY:5 COMMENTS:DEFICIENCIES.

10 FLUID Temp (C)Hydrogen (H2)Methane (CH4)Ethane (C2H6)Ethylene (C2H4)Acetylene (C2H2)Carbon Monoxide (CO)Carbon Dioxide (CO2)Nitrogen (N2)Oxygen (O2)TDCG (ppm)Total Gas (%)Equivalent TCG (%)Sample NoLimits< 100< 120< 65< 50< 35< 350< 2500< 720< 35 EQUIPMENT ConditionWater SaturationWaterO2/N2CO2/ AnalysisResultInterval (days)Gas StdPort or TankSampled byTest LabTest DateLab Ref NoReasonGas Analysis RemarksFluid QualityAcid NumberInterfacial TensionDiel Str (D1816)Diel Str (D877)PF at 25 CWaterWater SaturationSpecific GravityColorFluid / PCB CondSample NoFluid Temp (C)mg KOH/gmN/mkVkV%ppm% Limits< .15> 30> 47< .5< 20< 15< 3 Interval (days) FLUID StdPort or TankSampled byTest LabTest DateLab Ref NoReasonResultFluid Quality Analysis RemarksINSULATING FLUID ANALYSISC ooling AUTOMATED ManufacturerkV Rating MVA RatingExample Customer CompanyDescriptionPreservationOwnerLocat ionDesignation EQUIPMENT ID Apparatus Type FLUID TypeFluid Cap.