Fast, Simple QuEChERS Extraction and Cleanup of …

1 Restek Corporation, 1-800-356-1688 or Preparation ApplicationsFast, Simple QuEChERS Extraction andCleanup of Pesticide Residue SamplesQuick,Easy,Cheap,Effective,Rugged , and Safe, the QuEChERS ( catchers ) method for extracting pes-ticides from food is based on research by the US Department of addition to using less sol-vent and materials versus conventional SPE methods, QuEChERS employs a novel and much quicker dis-persive solid phase Extraction Cleanup (dSPE). QuEChERS methods, including an AOAC OfficialMethod2and modifications to the methods, have been posted on the methods have sev-eral basic steps in common: QuEChERS methods are convenient, rugged methods that simplify extract Cleanup , reduce material costs,and improve sample throughput. Here we demonstrate the effectiveness of QuEChERS sample cleanupusing a multiresidue analysis of pesticides on extracts were prepared, spiked, and dSPE treated according to Table I.

2 One microliter split-less injections of the extracts were performed by a Shimadzu AOC-20i autosampler using mid injectionspeed into a Shimadzu QP-2010 Plus GC-MS system operated under the conditions in Table and DiscussionPrimary and secondary amine exchange material (PSA) is the base sorbent used for dSPE Cleanup ofQuEChERS fruit and vegetable extracts because it removes many organic acids and sugars that might actas instrumental pesticide-spiked strawberry extract (200ng/mL) subjected to dSPE with PSA was used to generate one-point calibration curves. Spiked strawberry extracts subjected to additional dSPE sorbents were analyzedand the results versus PSA dSPE are shown as percent recoveries in Table III. C18 is suggested for usewhen samples might contain fats; not an issue for a strawberry extract, but it was important to verify thatgross losses of more hydrophobic pesticides ( , endrin and DDT) would not occur.

3 Graphitized carbonblack (GCB) is used to remove pigments, and when treated, the pink/red strawberry extract became , GCB can also have a negative effect on certain pesticides, especially those that can assume a planar shape like chlorothalonil and thiabendazole. Achieve a four-fold increase in sample throughput. Significantly reduce material costs. Convenient, ready to use centrifuge tubes withultra pure, pre-weighed adsorbent 1:Sample preparation and Extraction Commodities are uniformly solvent is added for a shake Extraction . Salts, acids, and buffers may be added toenhance Extraction efficiency and protect sensitive analytes. Surrogate standards can be addedto monitor Extraction 2:Extract Cleanup A subsample of solvent extract is cleaned up using dSPE, a keyimprovement incorporated in the QuEChERS technique. Small polypropylene centrifuge tubesare prefilled with precise weights of MgSO4and SPE adsorbents to remove excess water andunwanted contaminants from the extracted samples.

4 After agitation and centrifugation, thecleaned extracts are ready for analysis by a variety of 3:Sample analysis Samples may be pH adjusted to protect sensitive pesticides and/orsolvent-exchanged to improve analysis by either GC/MS or LC/MS. Internal standards can dSPE products, available in a variety of standard sizes, make QuEChERS even simpler. The cen-trifuge tube format contains magnesium sulfate (to partition water from organic solvent) and a choice ofSPE sorbents, including PSA (to remove sugars and fatty acids), C18 (to remove nonpolar interferencessuch as fats), and GCB (to remove pigments and sterols). Custom products also are available by you are frustrated by the time and cost involved with your current approach to pesticide samplecleanup, we suggest you try this Simple and economical new Corporation, 1-800-356-1688 or :Rtx -CLPesticides2, 20m, ID, m (cat.)

5 # 42302)Sample:custom pesticide mix, 200 g/mL each pesticide, internal standards: 8140-8141 ISTD, 1000 g/mL (cat.# 32279), ISTD 100 g/mL (cat.# 32091), triphenylphosphate 1000 g/mL (cat.# 32281)Inj. L splitless (hold 1 min.)Inj. temp.:250 CCarrier gas:heliumFlow rate: constant linear velocity @ 40cm/secOven temp.: 40 C (hold 1 min.) to 320 C @ 12 :Shimadzu GCMS-QP2010 PlusTransfer line temp.: 300 CIonization: Electron ionizationMode: Selected ion monitoringTable IIInstrument preparation and extractionSSaammppllee::10g of strawberries were homogenized and placed in a 50mL PTFE centrifuge tube (cat.# 26227)SSoollvveenntt::10mL of acetonitrile were added to homogenateShake for 1 minute, until MgSO4(powder or granular) trisodium citrate disodium hydrogencitrate sesquihydrateSalts were added and vigorously shaken for 1 minute. Sample was centrifuged and the supernatant removed for Cleanup .

6 Pesticides standards (200ng/mL) were spiked in at this extract cleanupQQuuEECChhEERRSS ttuubbeess::1mL of supernatant from the previous step was placed into several 2mL polypropylene centrifuge tubes, each containing one of the following adsorbent mixes:A. 50mg PSA + 150mg MgSO4(cat.# 26124)B. 50mg PSA + 150mg MgSO4+ 50mg C18 (cat.# 26125)C. 50mg PSA + 150mg MgSO4+ 50mg GCB (cat.# 26123) CClleeaannuupp::Samples were shaken with the adsorbents for 30 seconds (carbon for 2 minutes), then centrifuged to produce a clear supernatant for GC/MS analysis. IInntteerrnnaall ssttaannddaarrdd::Pentachloronitrobenzen e in a formic acid solution, pH 5. PSA primary and secondary amine exchange material. GCB graphitized carbon blackTable IQuEChERS Extraction and Cleanup procedure for pesticides from Michelangelo Anastassiades, Steven J. Lehotay, Darinka tajnbaher, Frank J. Schenck. fast and Easy Multiresidue Method EmployingAcetonitrile Extraction /Partitioning and Dispersive Solid-Phase Extraction for the Determination of Pesticide Residues in Produce.

7 J. AOACI nternational, 2003, vol. 86(22), AOAC Official Method , Pesticide Residues in Foods by Acetonitrile Extraction and Partitioning with Magnesium Sulfate. 3. Schenck, , SPE Cleanup and Analysis of PPB Levels of Pesticides in Fruits and Pesticide Residue Workshop, not available from Restek(cat.# 26213)MMuullttiippllee ssoorrbbeennttss aarree uusseedd ttoo eexxttrraacctt ddiiffffeerreenntt ttyyppeess ooff excess waterPSA*removes sugars, fatty acids, organic acids, and anthocyanine pigmentsC18removes nonpolar interferencesGCB**removes pigments, sterols, and nonpolar interferencesdid you know?*PSA primary and secondary amine exchange material. **GCB graphitized carbon blackRestek Corporation, 1-800-356-1688 or (( ))ppeessttiicciiddeeCCAASS NNuummbbeerraaccttiioonn//uusseeccllaass ssiiffiiccaattiioonnCC1188**GGCCBB** , *50mg PSA, 50mg C18, **50mg PSA, 50mg GCB Table IIIP esticide percent recoveries in strawberry extracts treated with C18 or GCB dSPE, relative to PSA recovery = RRF C18 or GCBX 100 RRF PSARtx -CLPesticides2(proprietary Crossbond phase) Application-specific columns for organochlorine pesticides and herbicides.

8 Low bleed ideal for GC/ECD or GC/MS analyses. Baseline separations in less than 10 (( mm)) ## to 310/330 C20-meter42302Q-sep 3000 Centrifuge for QuEChERS Meets requirements of AOAC and European QuEChERS methodology. Supports 50mL, 15mL, and 2mL centrifuge tubes. Small footprint requires less bench space. Safe and reliable UL, CSA, and CE approved, 1-year ## pprriicceeQ-sep 3000 Centrifuge, 3000 Centrifuge, AAcccceessssoorriieess50mL Tube Carrier for Q-sep 3000 Centrifuge Conical Tube Insert for Q-sep 3000 Tube Carrier for Q-sep 3000 Centrifuge Tube Adaptors for Q-sep 3000 Centrifuge !Lit. Cat.# GNAN1097A 2009 Restek Corporation. All rights # 26123cat. # 26124cat. # 26125cat. # 26126 QuEChERS SPE TubesQuick, Easy, Cheap, Effective, Rugged, and Safe, the QuEChERS ( catchers ) method is a fast , Simple , and effective alternative toconventional sample prep for multiresidue pesticide Q-sep products make QuEChERS even simpler.

9 Allextraction salts, adsorbents, and sample tubes are included nospecialized equipment or glassware is Sample Packs Available!To receive your free sample pack, add -248 to the item number. (One sample per customer.)cat. # 26227cat. # 26214htiw sgnivaSdeifidoM ro ekuL-iniMLuke MethodQuEChERSQuEChERSretsaf x403021).nim( selpmas 6 ssecorp ot emit detamitsEtnevlos ssel x9-60109-06 )Lm( desu tnevloSreneerg ,repaehc ,refaS003-02)Lm( etsaw detanirolhCGlassware/specialized equipmentcapacity for 200mL, quartz wool,none Ready-to-usefunnel, water bath or evaporatorPrepare samples more quickly, easily, and cost-ctively with #price50mL Centrifuge Tubes for Sample ExtractionQ1104g MgSO4, 1g NaCl, 1g trisodium citrate dihydrate, .5g disodium hydrogencitrate sesquihydrateEuropean EN CAOAcAOaN ,Empty CAOA ,26651 NE naeporuE ebuT egufirtneC2mL Micro-Centrifuge Tubes for dSPE (clean-up of 1mL extract)Q210150mg NE naeporuEASP gm52 ,Q211150mg 81C gm52 ,ASP gm52 ,Q212150mg NE naeporuEBCG ,ASP gm52 ,Q213150mg NE naeporuEBCG ,ASP gm52 ,Q250150mg CAOAASP gm05 ,Q251150mg CAOA81C gm05 ,ASP gm05 ,Q253150mg BCG gm05 ,ASP gm05 ,Q252150mg MgSO4, 50mg PSA, 50mg C18, 50mg GCBAOAC Centrifuge Tubes for dSPE (clean-up of 6mL extract)

10 Q3501200mg CAOAASP gm004 ,Q3511200mg CAOA81C gm004 ,ASP gm004 ,Q3521200mg MgSO4, 400mg PSA, 400mg C18, 400mg GCBAOAC NE naeporuEASP gm051 ,Q371900mg NE naeporuEBCG gm51 ,ASP gm051 ,Q372900mg NE naeporuEBCG gm54 ,ASP gm051 ,Q373900mg 81C gm051 ,ASP gm051 ,Q374900mg BCG gm051 ,ASP gm003 ,innovativechromatographysolutionsVisit detailedtechnical literature anda complete line of QuEChERS in the 110 Benner Circle Bellefonte, PA 16823 1-814-353-1300 1-800-356-1688 fax: 1-814-353-1309 phone: +86-10-5629-6620 fax: +86-10-5814-3980 phone: +33 (0)1 60 78 32 10 fax: +33 (0)1 60 78 70 90 phone: +49 (0)6172 2797 0 fax: +49 (0)6172 2797 77 phone: +39-02-7610037 fax: +39-02-70100100 phone: +81 (3)6459 0025 fax: +81 (3)6459 0025 e-mail: phone: +44 (0)1494 563377 fax: +44 (0)1494 564990 & TRADEMARKSR estek patents and trademarks are the property of Restek Corporation.