FINAL INVESTIGATION REPORT ON ACCIDENT TO …

1 FINAL INVESTIGATION REPORT ON ACCIDENT TO NATIONAL. AEROSPACE LABORATORIES, BANGALORE SARAS PT2. aircraft VT XRM AT SESHAGIRIHALLI NEAR BIDADI. (KARNATAKA) ON 6 TH MARCH 2009. 1. aircraft Type & model : Saras Prototype PT 2. Nationality : Indian Registration : VT-XRM. Engine : P&W,PT6A-67A. 2. Owner & Operator : National Aerospace Laboratories :1779, Kodihalli Bangalore-560017. 3. a) Pilot-in command : Wg Cdr (22917-S),F(P). b) co-pilot : Wg Cdr (23165-H),F(P). c) Flight test engineer : Sqn Ldr (24746-M),AE(M). b) Extent of injuries : Fatal 4. a) Number of passengers : Nil b) Extent of injuries : N/A.

2 5. Place of ACCIDENT : Seshagirihalli , near Bidadi about 37 Km Southwest of HAL. airport, Bangalore Latitude: N 12 50' 56 . Longitude: E 077 23' 46 . 6. Date and time of ACCIDENT : 6th March 2009, appr 1004 UTC. (All Timings in this REPORT are in UTC). SYNOPSIS. Saras Prototype PT2 aircraft VT -XRM manufactured and owned by National Aerospace Laboratories, Bangalore was scheduled for carrying out its test flight no 49. On which also include inflight engine shut down and relight procedure at 10000'AMSL . Chief test pilot was on commander seat , test pilot was on co -pilot seat and Flight test engineer was also on board.

3 aircraft took-off at 0925 UTC and thereafter changed over to radar. There was no events. aircraft was then cleared to flight level 100, operate up -to 10miles. After completing general handling checks at 9000'AMSL without any events, Single engine simulated approach was carried out on r/w 09. At about 0941 UTC aircraft was cleared for overshoot, wind 090/06 kts. aircraft made overshoot at 300'AGL. aircraft was then changed over to radar again. At 0942 UTC aircraft was cleared to climb FL100 and pr oceed sector Southwest 2 for carrying out engine relight test procedure.

4 After climbing to about 9000'AMSL in sector Southwest aircraft reported 15 miles and FL 90 at about 0948 UTC. 1. and reported turning around. But HAL radar as well BIAL radar was showing level 72 for which aircraft replied that it has descended and climbing back to 9000'AMSL. At about 0956. UTC aircraft reported OPS NORMAL at 20Nm in sector Southwest 2. This was the last contact of aircraft with radar but was in contact with FTD telemetry desk of ASTE, Bangalore. After successful left engine shut down and its securing procedure, at about 1001.

5 UTC left engine relight procedure was initiated at about 9200'AMSL. During the relighting of left engine, FTD desk also lost contact with aircraft about 37 secs prior to crash. aircraft crashed at about 1004 UTC. There was no response from pilots even after repeated calls made by the Radar controller as well as FTD desk. Radar contact with the aircraft was also completely lost. All possibl e communication means including through en -route traffic to contact the aircraft went in vain. After extensive search efforts, at about 1100 UTC it was finally established that the aircraft crashed at a village called Sehsagirihalli (close to wonderland amusement park) near Bidadi, 37km by road (1km off Mysore road) southwest of HAL airport, Bangalore.

6 All the three persons on board were charred to death. There was post impact fire. aircraft was completely destroyed due impact and fire. 1. Factual Information : History of the flight On Saras Prototype PT2 aircraft VT -XRM manufactured and owned by National Aerospace Laboratories, Bangalore was scheduled for carrying out its test flight no 49 . Test flight programme includes general a ir tests/handling checks to ascertain the aircraft flying characteristics after the 50 hrs Scheduled servicing, dummy approach in simulated single engine configuration at 5000'AMSL, go around at 300'AGL in a simulated one engine inoperative condition, land ing in a simulated one engine inoperative condition and to carry out in-flight engine shut down and relight procedure at 10000'AMSL within 130 -150 kts speed.

7 Tests are to be carried out as per existing SOP and test procedures and limitations and pre flight test briefing meeting. aircraft was cleared by approved inspectors of NAL after carrying out daily inspection on for test flight No:49 and was duly accepted by the Chief test pilot. Preflight briefing was taken by the Wg Cdr (22917-S), F(P), chief test pilot was on commander seat , Wg Cdr (23165-H), F(P) - test pilot was on co-pilot seat and Sqn Ldr (24746-M), AE(M) was on Flight test engineer on board. The test team also accepted flight test schedule of flight No:49.

8 Total duration of the tests was estimated to about 45. minutes. Engines were started at 0913 UTC at ASTE, dispersal area . All engine parameters were reported normal. After carrying out post start up and pre taxy checks, aircraft taxied out for Runway 09 at HAL airport. As pe r departure instructions after departure R/W 09 aircraft to climb on R/W heading 5000', turn right set course to southwest -2 and in coordination with approach radar to operate upto 10 miles and level 100. aircraft was cleared for take -off from R/W 09 with surface wind 090 /06kts.

9 aircraft took-off at 0925 UTC and changed over to radar at 0926 UTC. There was no event. aircraft was then cleared to level 100, operating upto 10miles. After completing general handling checks at 9000'AMSL without any events, aircraft was stabilized with simulated single engine approach to the landing r/w 09. Single engine simulated approach was carried out. At about 0941 UTC aircraft was cleared for overshoot, wind 090/06 kts. aircraft made overshoot at 300'AGL. aircraft was t hen changed over to radar again. At 0942 UTC aircraft was cleared to climb level 100 and proceed sector southwest 2.

10 aircraft right engine was throttled up to match left engine and aircraft climbed 2. out to 9000'AMSL in sector southwest. At about 0948 UTC aircraft reported 15 miles and FL. 90 and reported turning around. But HAL radar as well as BIAL radar showing level was 72. for which aircraft replied that it has descended and climbing back to 9000'AMSL. At about 0955 UTC aircraft reported OPS NORMAL at 20 Nm in sector southwest 2. This was the last contact by aircraft with radar. After 0955 UTC Radar contact with the aircraft was completely lost. As per ASTE Telemetry, after turned round to point towards HAL airfield aircraft was observed about 20 miles at 9000'AMSL with 140 kts speed.