FLUID CAPACITY CHART - Genuine VW Parts Are …

1 FLUID CAPACITY CHARTE2003 Volkswagen of America, rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rightsof Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means,electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the /VEHICLEENGINE OIL (Rev 11/04)MANUAL TRANS.

2 (Rev 11/04)AUTOMATICTRANS. DIFFERENTIALAUTOMATIC TRANS. COOLING SYSTEM POWERSTEERING WINDSHIELDWASHER A/C REFRIGERANTR-134a A/C REFRIGERANT OIL Jetta/GolfGTIJ ettaWagon2003w/filter (AWP) ( qt) (ALH) ( qt) (AZG) ( qt) (BDF) ( qt) ( qt) ( qt)01 MNew fill: ( qt)Refill: ( qt)09 ANew fill: L( qt)See VESISfor filling afterrepairswith trans 02mNew fill: ( qt)See VESIS for fillingafter repairswith trans 09 ACapacity included withAutomatic TransmissionSee VESIS for fillingafter T (AWP) ( qt) (ALH) ( qt) (AZG) ( qt) (AFP) ( qt) ( qt) ( )750+50 g(26+ oz)135+15 cc( + fl. oz) ENGINE OIL:Approximate quantities!

3 Gasoline engines: Use API SERVICE SL or SJ, Either VW 502 00, VW 500 00 or VW 501 01, ACEA A3. Diesel engines: UseAPI SERVICE CF4, API SERVICE CG4, VW 505 00, ACEA B3, or ACEA B4. Do not overfill! Overfilling engine oil can cause misfire DTC s to be stored in EngineControl Module (ECM) -J220-. To prevent overfilling, add approx. less than CAPACITY , start engine and let run until engine operating temperature is (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for engines only:After changingoil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, as this could cause damage to/ failure of the turbocharger.

4 MANUAL TRANS: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2 for02M, Use mineral oil SAE 75W90, Part No. G 052 726 A2 for02J. AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2(1 liter container) for 01M trans, G 052 990 A2(1 liter container) for 09A Life-time filling, newfill quantity is for reference only. Only replace after repair ( when removing oilpan). See Repair Manual (VESIS) for details. DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2(1 liter container) . Life-time filling, new fill quantity is forreference only. Only replace after repair. See Repair Manual(VESIS) for details.

5 COOLING SYSTEM: Use only phosphate-freecoolant G 012 A8F A4,PURPLE NOT INTERCHANGE OR MIXolder G11(ZVW 237 105), can result in serious damage to the engine. However, it may be mixed with ZVW 237 G12, PINK protection is required down toapproximately -25_C (-13_F). In countries with arctic climates, frost protection is required down to approximately --35_C(--31_F). The anti-freeze ratio must bea minimum of 40%, as otherwise frost protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very coldclimates),theamount of G 012A8F A4canbeincreased, but only upto60%. This provides frost protectiontoapprox.

6 -40_C(--40_F). Donot reducethecoolantconcentrationby adding water, even in warmer seasons and in warmer countries, as cooling effectiveness will be reduced. POWER STEERING: Hydraulic oil G 002 012. Do not use ATF. WINDSHIELD WASHER: Concentrated ZVW 177 901/903/904/906. Windshield container also serves for rear washer in Jetta Wagon. A/C REFRIGERANT: Use R-134a A/C REFRIGERANT OIL: Use PAG oil, Part No. G 052 154 A2 w/ Sandon comressor, (G052 300A2, or G 052 w/Zexel compressor) with : Part numbers are for reference only. Always check with your Parts Dept. for the latest Parts CAPACITY CHARTE2003 Volkswagen of America, rights reserved.

7 Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rightsof Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means,electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the /VEHICLEENGINE OIL (Rev 11/04)MANUAL TRANS.

8 (Rev 11/04)AUTOMATICTRANS. DIFFERENTIALAUTOMATIC TRANS. COOLING SYSTEM POWERSTEERING WINDSHIELDWASHER A/C REFRIGERANTR-134a A/C REFRIGERANT OIL NewBeetle2003w/filter (AWV) (AWP) ( qt) (ALH) ( qt) (AZG) ( qt) ( qt) ( qt)01 MNew fill: ( qt)Refill afterrepair:approx. ( qt)See VESISfor filling afterrepairsNew fill: ( qt)Filled for VESIS for fillingafter (AWV) (AWP) ( qt) (ALH) ( qt) (AZG) ( qt) L( qt) ( qt)700+50 g( + oz)135 cc( + fl. oz) ENGINE OIL:Approximate quantities!Gasoline engines: Use API SERVICE SL or SJ,Either VW 502 00, VW 500 00 or VW 501 01, ACEA A3. Diesel engines: UseAPI SERVICE CF4, API SERVICE CG4, VW 505 00, ACEA B3, or ACEA B4.

9 Do not overfill! Overfilling engine oil can cause misfire DTC s to be stored in EngineControl Module (ECM) -J220-. To prevent overfilling, add approx. less than CAPACITY , start engine and let run until engine operating temperature is (140_F), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for engines only:After changingoil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, as this could cause damage/ failure of the turbocharger. MANUAL TRANS: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2 for02M, Use mineral oil , SAE 75W90 Part No.

10 G 052 726 A2 for02J. AUTOMATIC TRANS: Use VW ATF, Part No. G 052 162 A2(1 liter container). Life-time filling, new fill quantity is for reference only. Only replace after repair( when removing oil pan). SeeRepair Manual (VESIS)for details. DIFFERENTIAL AUTOMATIC TRANS: Use synthetic gear oil, SAE 75W90, Part No. G 052 145 S2(1 liter container). Life-time filling, new fill quantity is forreference only. Only replace after repair. See Repair Manual (VESIS) for details. COOLING SYSTEM: Use only phosphate-freecoolant G 012 A8F A4,PURPLE NOT INTERCHANGE OR MIXolder G11(ZVW237 105),GREENCOLORED. This can result in serious damage to the engine.