1 installation , Operation, and Maintenance Packaged Rooftop Air Conditioners Foundation Gas/Electric 3 to 5 Tons, 60Hz Model Numbers: GBC036-060. SAFETY WARNING. Only qualified personnel should install and service the equipment. The installation , starting up, and servicing of heating, ventilating, and air-conditioning equipment can be hazardous and requires specific knowledge and training. Improperly installed, adjusted or altered equipment by an unqualified person could result in death or serious injury. When working on the equipment, observe all precautions in the literature and on the tags, stickers, and labels that are attached to the equipment.
2 August 2017 RT-SVX058B-EN. Introduction Read this manual thoroughly before operating or servicing this unit. WARNING. Warnings, Cautions, and Notices Proper Field Wiring and Grounding Required! Safety advisories appear throughout this manual as Failure to follow code could result in death or serious required. Your personal safety and the proper operation of injury. All field wiring MUST be performed by qualified this machine depend upon the strict observance of these personnel. Improperly installed and grounded field precautions.
3 Wiring poses FIRE and ELECTROCUTION hazards. To avoid these hazards, you MUST follow requirements for field wiring installation and grounding as described in The three types of advisories are defined as follows: NEC and your local/state electrical codes. Indicates a potentially hazardous WARNING situation which, if not avoided, could result in death or serious injury. WARNING. Indicates a potentially hazardous Personal Protective Equipment (PPE). CAUTIONs situation which, if not avoided, could result in minor or moderate injury.
4 It Required! could also be used to alert against Failure to wear proper PPE for the job being undertaken unsafe practices. could result in death or serious injury. Technicians, in order to protect themselves from potential electrical, NOTICE Indicates a situation that could result in mechanical, and chemical hazards, MUST follow equipment or property-damage only precautions in this manual and on the tags, stickers, accidents. and labels, as well as the instructions below: Important Environmental Concerns Before installing/servicing this unit, technicians MUST put on all PPE required for the work being Scientific research has shown that certain man-made undertaken (Examples; cut resistant gloves/sleeves, chemicals can affect the earth's naturally occurring butyl gloves, safety glasses, hard hat/bump cap, fall stratospheric ozone layer when released to the protection, electrical PPE and arc flash clothing).
5 Atmosphere. In particular, several of the identified ALWAYS refer to appropriate Material Safety Data chemicals that may affect the ozone layer are refrigerants Sheets (MSDS)/Safety Data Sheets (SDS) and OSHA. that contain Chlorine, Fluorine and Carbon (CFCs) and guidelines for proper PPE. those containing Hydrogen, Chlorine, Fluorine and When working with or around hazardous chemicals, Carbon (HCFCs). Not all refrigerants containing these ALWAYS refer to the appropriate MSDS/SDS and compounds have the same potential impact to the OSHA/GHS (Global Harmonized System of environment.)
6 Trane advocates the responsible handling of Classification and Labelling of Chemicals) guidelines all refrigerants-including industry replacements for CFCs for information on allowable personal exposure such as HCFCs and HFCs. levels, proper respiratory protection and handling Important Responsible Refrigerant instructions. Practices If there is a risk of energized electrical contact, arc, or flash, technicians MUST put on all PPE in accordance Trane believes that responsible refrigerant practices are with OSHA, NFPA 70E, or other country-specific important to the environment, our customers, and the air requirements for arc flash protection, PRIOR to conditioning industry.
7 All technicians who handle servicing the unit. NEVER PERFORM ANY. refrigerants must be certified. The Federal Clean Air Act SWITCHING, DISCONNECTING, OR VOLTAGE. (Section 608) sets forth the requirements for handling, TESTING WITHOUT PROPER ELECTRICAL PPE AND. reclaiming, recovering and recycling of certain ARC FLASH CLOTHING. ENSURE ELECTRICAL. refrigerants and the equipment that is used in these METERS AND EQUIPMENT ARE PROPERLY RATED. service procedures. In addition, some states or FOR INTENDED VOLTAGE. municipalities may have additional requirements that must also be adhered to for responsible management of refrigerants.
8 Know the applicable laws and follow them. 2017 Ingersoll Rand RT-SVX058B-EN. Introduction WARNING. Follow EHS Policies! Failure to follow instructions below could result in death or serious injury. All Ingersoll Rand personnel must follow Ingersoll Rand Environmental, Health and Safety (EHS). policies when performing work such as hot work, electrical, fall protection, lockout/tagout, refrigerant handling, etc. All policies can be found on the BOS. site. Where local regulations are more stringent than these policies, those regulations supersede these policies.
9 Non-Ingersoll Rand personnel should always follow local regulations. NOTICE. Water Damage! Non-factory penetrations through the base of this unit are not allowed. Any penetration in the base of the unit may affect the water tight integrity of the unit and lead to water leaks into the conditioned space. Failure to follow instructions could result in equipment and property damage. Copyright This document and the information in it are the property of Trane , and may not be used or reproduced in whole or in part without written permission.
10 Trane reserves the right to revise this publication at any time, and to make changes to its content without obligation to notify any person of such revision or change. Trademarks All trademarks referenced in this document are the trademarks of their respective owners. Should equipment failure occur, contact a qualified service organization with qualified, experienced HVAC. technicians to properly diagnose and repair this equipment. Revision History Updated the Condensate Drain Configuration' section. RT-SVX058B-EN 3. Table of Contents Model Number Description.