KIA DOT 3 Motor Vehicle Brake Fluid

1 1 Safety Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake FluidSECTION 1: IDENTIFICATION Product identifier Product :KIA DOT 3 Motor Vehicle Brake FluidSynonyms :NoneProduct Part Number:UM040 CH Relevant identified uses of the substance or mixture and advised againstBrake Detail of the supplier of the safety data sheetManufacturerNameCCI MANUFACTURING IL CORPORATIONA ddress 15550 Canal Bank Road, Lemont, IL 60439 Telephone(630) Emergency telephone numberINFOTRAC: 1-800-535-5053 - DOMESTIC1-352-323-3500 - INTERNATIONALSECTION 2: HAZARD Classification of the substance or mixtureHealth Hazard Classification:Physical Hazard Classification:Not Label elementsHazard PictogramsGHS07 GHS05 Signal wordDangerHazard statementsH302 Harmful if swallowedH316 Causes mild skin irritationH318 Causes serious eye damageSerious Eye Damage/Eye Irritation1H318 Acute Toxicity (Oral)4H302 Skin Corrosion/Irritation3H31610754 February 24, 2015 March 4, 2019 HazardCategoryCode2 Safety Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, 2019 Precautionary statementsPreventionP264 Wash face, hands and any exposed skin thoroughly after handling.

2 P270Do not eat, drink or smoke when using this product. P280 Wear eye protection/face + P312IF SWALLOWED: Call a POISON CENTER or doctor/physician if you feel unwell. P330 Rinse mouth. P332 + P313If skin irritation occurs: Get medical advice/attention. P305 + P351 + P338P310 Immediately call a POISON CENTER or doctor/physician. StorageNoneDisposalP501 Dispose of contents/container in accordance with applicable federal, state and local regulations. Other hazardsData not availableSECTION 3: COMPOSITION/INFORMATION ON MixturesComponentsCAS %Hazard CodeDiethylene Glycol111-46-620 - 50 %H302 Triethylene glycol monobutyl ether143-22-645 - 55 %H318 Mixture of other glycol ether, glycol Proprietary15 - 25 %H316derivative, glycol ether borate ester SECTION 4: FIRST AID Description of first aid measuresSkin, eye andSwallowing:Skin Contact:Eye Contact: Most important symptoms and effects, both acute and delayedThe most important known symptoms and effects are described in the labelling (see section ) and/or in section flush with water for 15 minutes.

3 Wash the contaminated skin with soap and water. If irritation develops, call a physician. If clothing comes in contact with the product, the clothing should be laundered before flush with large amounts of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Call a physician at product is not toxic by inhalation. Remove individual to fresh IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue items on this SDS are designated as trade secrets. Requests for disclosure of trade secret information will be made in accordance with the provisions contained in OSHA 29 CFR (i).Get medical advice/attention if you feel Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, Indication of any immediate medical attention and special treatment neededSECTION 5 : FIREFIGHTING Extinguishing Special hazards arising from the substance or mixtureData not Advice for firefightersSECTION 6: ACCIDENTAL RELEASE Personal precautions, protective equipment and emergency Environmental precautionsThe product should not be dumped in nature but collected and delivered according to agreement with the local Method and material for containment cleaning Reference to other sectionsFor disposal see section 7.

4 HANDLING AND Precautions and safe handling- Do not expose children and pets to this After handling product, wash thoroughly with soap and water before drinking, eating, or Keep away from open Conditions for safe storage, including any Specific end use(s)The identified uses for this product are detailed in section personal precautions, protective equipment and emergency procedures, see section 8. In case of spills, beware of slippery floors and up with inert absorbent material and dispose in accordance with local/resional/national/international regulations. Keep in suitable, closed containers for Do not store at temperatures above 104 F; Normal room temperature is satisfactory. Incompatible with strong acids, bases and oxidizers, chromium trioxide, potassium permanganate, and sodium recommendation given, but first aid may still be required in case of accidental exposure, inhalation or ingestion of this chemical.

5 If in doubt, GET MEDICAL ATTENTION PROMPTLY!Individuals should perform only those firefighting procedures for which they have been trained. Use water spray, dry chemical, alcohol foam or carbon dioxide. Use water to keep fire-exposed containers cool. If a spill or leak has not ignited, use water spray to disperse the vapors. Water spray may be used to flush spills away from fire and diluted spills to noncombustible proportions(see warning on water spray on hot liquid below.)Fire fighters should wear self-contained breathing apparatus in the positive pressure mode with a full face piece when, there is a possibility of exposure to smoke, fumes or hazardous decomposition products. Water spray may cause foaming of hot glycol so indirect application of water spray or use of other extinguishing media should be used on hot Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, 2019 SECTION 8 : EXPOSURE CONTROLS/PERSONAL Control Exposure controlsControl Measures :Respiratory Protection :Protective Clothing :Eye Protection :SECTION 9.

6 PHYSICAL AND CHEMICAL Information of basic physical and chemical propertiesAuto ignition temperatureData not availableDecomposition temperatureData not availableViscosityData not availableDensity (20 C) g/cm3 Solubility in WaterCompletePartition coefficient n-octanol/waterData not availableUpper/Lower flammability or explosive limitsData not availableVapor pressureBelow mmHgVapor Density (Air = 1)Data not availableFlash point132 C (270 F, COC)Evaporation rateData not availableFlammability(Solid, gas)Data not (50 v/v%)Freezing pointData not availableInitial boiling point and boiling rangeHigher than 240 C (464 F)AppearanceClear to amber, homogeneous liquidOdorMild, characteristicOdor thresholdData not availableTWAH andle in the presence of adequate ventilation. Engineering controls should be used whenever feasible to maintain concentrations below acceptable exposure criteria, including enclosures and local exhaust exposure is likely to exceed acceptable criteria and engineering controls are not feasible, use NIOSH/MSHA approved respiratory protection equipment.

7 Respirators should be selected based on the form and concentration of contaminants in air and in accordance with OSHA (29 CFR )Wear gloves and protective clothing which are impervious to the product for the duration of exposure if there is potential for skin safety glasses meeting the specifications of ANSI Standard where no contact with the eye is anticipated. Chemical safety goggles meeting the specification of ANSI Standard should be worn whenever there is the possibility of splashing or other contact with the Glycol111-46-6US OSHANoneNoneUS ACGIHNoneNoneUS AIHA (WEEL)10 mg/m3 ComponentCAS LimitNotes5 Safety Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, Other informationNoneSECTION 10 : STABILITY AND ReactivityHazardous Polymerization :Not likely to occurConditions and Materials to Avoid Chemical stabilityGenerally Possibility of hazardous reactionsData not Conditions to avoidAvoid heat, flames and other sources of Incompatible materialsData not Hazardous decomposition productsHazardous Decomposition Products :SECTION 11:TOXICOLOGICAL Information on toxicological effectsInhalation:Ingestion:The acute oral toxicities of the main components of this mixture are as follows.

8 Diethylene Glycol:Acute oral LD50's = 12,600 mg/kg (rat) 23,700 mg/kg (mouse)Eye Contact:Skin Contact:Chronic Effects: No chronic or delayed effects have been 12: ECOLOGICAL ToxicityEcological information of the product : Data not availableNTP: No component of this product present at levels greater than or equal to is identified as a known or anticipated carcinogen by : No component of this product present at levels greater than or equal to is identified as a carcinogen or potential carcinogen by information of the main ingredient of the product:Avoid concentrated strong acids, oxidizing agents and bases. Do not expose to open monoxide, carbon dioxideInhalation of vapors/mists may cause respiratory irritationBased on the pH and irritation potential of this mixture s constituents, the mist or liquid can be expected to cause mild to moderate irritation or inflammation of the eyesIf significant quantities of this mixture come into contact with the skin, it may cause mild irritation consisting of transient : No component of this product present at levels greater than or equal to is identified as probable, possible or confirmed human carcinogen by Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, 2019 Diethylene Glycol : LC50 - Pimephales promelas (fathead minnow) - 75,200 mg/l - 96 Persistence and degradabilityData not Bioaccumulative potentialData not Mobility in soilMobility: The product is miscible with water.

9 May spread in water Results of PBT and vPvB assessmentPBT assessment results: This substance is not classified as PBT or Other adverse effectsOther adverse effects / Remarks: None Disposal :SECTION 14 : TRANSPORT UN numberNot UN proper shipping nameNot Transport hazard class(es)DOT Classification (Bulk) :Not DOT ClassificationDOT Classification (Non-bulk) :Not applicableIATA (Non-bulk) :Not regulatedIMDG Code (Non-bulk) :Not Packaging groupNot Environmental hazardsMarine pollutant: NoPoison Inhalation Hazard: NoCare must be taken to prevent environmental contamination from the use of this material. The use of this material has the responsibility to dispose of unused material., residues and containers in compliance with all relevant local, state and federal laws and regulations regarding treatment, storage and disposal for hazardous and nonhazardous 13: DISPOSAL CONSIDERATIONSD isposal should be made in accordance with applicable federal, state and local regulations.

10 All recovered material should be packaged, labeled, transported, and disposed of or reclaimed in conformance with good engineering practices. Avoid land filling of liquids. Reclaim where this product becomes a waste, it DOES NOT meet the criteria of a hazardous waste as defined under 40 CFR 261, in that it does not exhibit the characteristics of hazardous waste of Subpart C, nor is it listed as a hazardous waste Subpart Data SheetSDS Date:Revision Date:KIA DOT 3 Motor Vehicle Brake Fluid10754 February 24, 2015 March 4, Special precautions for userData not Transport in bulk according to Annex II of MARPOL 73/78 and the IBC CodeData not availableSECTION 15 : REGULATORY Safety, health and environmental regulations/legislation specific for the substance or mixtureToxic Substance Control ActSARA Hazard Categories (as defined in Section 311/312)HealthImmediate (Acute) and Delayed (Chronic)PhysicalNoneWorkplace Hazardous Materials Information System Class D.