Transcription of MATERIAL SAFETY DATA SHEET - qualitychemical.ca
1 Safe T SorbMSDS12-504 MATERIAL SAFETY data SHEETS ection I: Manufacturer Customer Service: Extension 149 Moltan Company Phone: 800-264-5826 7125 Riverdale Bend Road 901-755-5666 Memphis, TN 38125-4442 Fax: 901-757-0546 MATERIAL Name: Safe T SorbChemical Name: MontmorillonitePrepared: March 1, 2004 Section II: Hazardous Ingredients/Identity InformationIngredient CAS Number Approx. % Exposure LimitMontmorillonite Clay, Calcined 70892-59-0 87-90 PEL: 5mg/m_ TWA respirable fraction TLV: 3mg/m_ TWA respirablefraction TLV: 10mg/m_ TWA inhalable fractionCrystalline Silica (Quartz) 14808-60-7 7-10 PEL:10mg/m_/%SiO2+2 TWA 3-4% Respirable TLV: Silica (Cristobolite) 14464-46-1 < 3 PEL: 5mg/m_/%SiO2+2 TWA TLV: TWAS ection III.
2 Physical/Chemical CharacteristicsBoiling PointN/A Specific Gravity (Water=1) Pressure (mm Hg)N/A Melting Point N/AVapor Density (Air = 1)N/A Evaporation Rate N/ASolubility in Water< Appearance & Odor: Tan to gray odorless solidSection IV: Fire & Explosion Hazard DataFlash PointN/A Flammable Limits N/AExtinguishing MediaN/A LEL N/A UEL N/ASpecial Fire Fighting Procedures: None Unusual Fire & Explosion Hazards: NoneSection V: Reactivity data Stability: Stable Hazardous Polymerization: Will not occurHazardous decomposition products: NoneIncompatibility: Unsaturated organic compounds, such as turpentine and vegetable oil, and hydrofluoric acid, may generate heat upon mixing with dry T SorbMSDS12-504 Section VI: Health Hazard DataRoutes of EntryInhalation?
3 YesSkin? NoIngestion? NoHealth Hazards Chronic: Years of exposure above the TWA/PEL may cause(Acute & Chronic) has classified crystalline silica as a probable : NTP? Respirable IARC Monographs? 68 OSHA Regulated? YesSigns & Symptoms of Exposure: Cough and shortness of breathMedical Conditions Aggravated by Exposure: Asthma and other preexisting respiratory and lung diseasesEmergency & First Aid Procedures: If symptoms occur, remove to fresh VII: Precautions for Safe Handling & UseIn Case of Release or Spill:Sweep up and reuse or dispose in sanitary landfillStoring & Handling Precautions: NoneOther Precautions: NoneSection VIII: Control MeasuresRespiratory ProtectionUse NIOSH approved dust mask when high dust levels are.
4 Local ExhaustYesSpecialNone MechanicalN/AOtherNoneProtective GlovesNoneEye ProtectionSafety glassesOther ProtectionNoneWork/Hygienic PracticesMinimize dustSection IX: Other InformationNFPA Rating: Health=1, Fire=0, Reactivity=0 HMIS Rating: Health=1, Fire=0, Reactivity=0 TSCA: All product components are listed on the EPA TSCA or exempt from notification DSL: All product components are listed on the Canadian Domestic Substance List or exempt from notification requirementsThis information is believed to be accurate. The Moltan Company makes no warrant, expressed orimplied, and assumes no responsibility as to the accuracy or suitability of this information forapplication to user s intended purposes or consequences of its use.
