Material Safety Data Sheet - Summitville Tiles

1 Chemical NameMATERIAL Safety data SHEETMANUFACTURER: Summitville LABORATORIES, self leveling UNDERLAYMENTPRODUCT NUMBER:58-00-9345 PRODUCT NAME:S-2200 self leveling UNDERLAYMENTSYNONYMS:PORTLAND CEMENT, SILICA SAND, LATEXUPC NUMBER:PREPARED BY: Safety ManagerDATE PREPARED:3/29/00PO BOX 9081 ARBOR ROADMINERVA, OH 44657 INFORMATION PHONE:330-868-6463 EMERGENCY PHONE:330-223-15111. CHEMICAL PRODUCT AND COMPANY IDENTIFICATIONLAST REVISION:9/13/992. COMPOSITION/INFORMATION ON INGREDIENTS3. HAZARDOUS IDENTIFICATIONEYE CONTACT:Can cause severe eye irritationSKIN CONTACT:Prolonged exposure may cause skin :Prolonged exposure to silicon doixide dust can cause delayed (chronic) lung injury (silicosis).INGESTION:May cause severe and permanent damage to mouth, throat, stomach, and digestive HEALTH EFFECTSEMERGENCY OVERVIEW:This Material is not flammable or reactive; but should be stored in a dry area to preserve AND SYMPTOMS OF EXPOSURE:Shortness of breathing, confused behavior, redness of skin, swelling of tissues, watery eyes, FIRST AID MEASURESEYE CONTACT:Immediately flush with plenty of water.

2 After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined and tested by medical :Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention :If swallowed, drink large amounts of water and induce vomitting. Never give anything by mouth to an unconscious person. Seek medical attention CONTACT:Wash affected area with soap and water. If irritation persists, get medical #OSHA PELACGIH TLVPORTLAND CEMENT MIXTURE65997151 PEL = (TOTAL DUST) 15 MG/M3; (RESPIRABLE FRACTION) 5mg/M3 TLV = 10mg/M3 SILICA, CRYSTALLINE - QUARTZ14808607 PEL = SEE TABLE Z-3 TLV = respirable dustVinyl Acetate/Ethylene Copolymer24937788N/EN/EPage 1 of 4S-2200 self leveling UNDERLAYMENTAUTOIGNITION:N/ACOMBUSTION PRODUCTS:N/AAGGRAVATED MEDICAL CONDITIONS:Frequent and prolonged contact with eyes and skin can cause irritation.

3 Prolonged exposure above guidelines may cause HEALTH INFORMATION:N/ASTEPS TO BE TAKEN IN CASE Material IS SPILLED OR RELEASED:Keep dust to a minimum. Material may be swept by personnel wearing appropriate protective FIRE FIGHTING MEASURESFLAMMABLE PROPERTIESFLASH POINT:N/ALEL:UEL:FLASH POINT METHOD USED:N/ASPECIAL FIRE FIGHTING PROCEDURES:N/AUNUSUAL FIRE AND EXPLOSION HAZARDS:None MEDIA:Generally non-flammable. Use appropriate media for surrounding ACCIDENTAL RELEASE MEASURES7. HANLDING AND STORAGEPRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:Avoid storing Material in areas where it will be exposed to high humidity and/or moisture. Material will solidify when exposed to PRECAUTIONS:N/A8. EXPOSURE CONTROL/PERSONAL PROTECTIONRESPIRATORY PROTECTION:Proper ventilation required.

4 Wear an appropriate cartridge respirator when strong odor and poor ventilation are present. VENTILATION:Controllling airborne concentration below the ACGIH TLV exposure guideline is recommended. Use only with adequate ventilation. Local exhaust ventilation may be necessary for some operations. Page 2 of 4S-2200 self leveling UNDERLAYMENTPERCENT VOLATILE:N/APH:N/AFREEZING POINT:N/AMOLECULAR WEIGHT:OTHER PROPERTIES:ENGINEERING CONTROLS:Facilities storing or utilizing this Material should be equipped with an eyewash facility and a Safety GUIDELINES:N/AOTHER PROTECTIVE CLOTHING OR EQUIPMENT:Where splashing is possible, wear protective apronEYE PROTECTION: Safety glasses with side shields (or goggles) as GLOVES:Wear rubber or latex gloves to reduce skin / HYGENIC PRACTICES:Use good personal hygiene when handling this product.

5 Wash hands after use, before smoking, or using the PHYSICAL AND CHEMICAL PROPERTIESSOLUABILITY IN WATER:Portland cement portion reacts with waterAPPEARANCE AND ODOR:Powder. Little to no odor. Color POINT:N/AVAPOR PRESSURE:N/AEVAPORATION:N/ASPECIFIC GRAVITY:~ DENSITY:N/AMELTING POINT:N/APOUNDS PER GALLON:N/A10. STABILITY AND REACTIVITYINCOMPATIBILITY:Oxidizing materials and DECOMPOSITION OR BY PRODUCTS:N/ASTABLE:StableHAZARDOUS POLYMERIZATION:Will Not OccurPage 3 of 4S-2200 self leveling UNDERLAYMENTN/AN/A11. TOXICOLOGY INFORMATION12. ECOLOGICAL INFORMATIOND isclaimerThe information contained herein is based on the data available to us and is believed to be accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof.

6 We assume no responsibility for injuries from the use of the product described DISPOSAL CONSIDERATIONSMay be disposed of in a sanitary landfill. Always follow appropriate Federal, District, State, Regional, and Local disposal TRANSPORTATION INFORMATIONDOT CLASS:Not RegulatedUN NUMBER:Not RegPACKING:Not RegGUIDE NUMBER:N/RPROPER SHIPPING NAME:Not RegulatedHAZARD CLASS:Not Reg15. REGULATORY INFORMATIONThis product contains the following materials reportable under California Proposition 65: Acetaldehyde - CAS # 75070, Lithium Carbonate - CAS # 55413216. OTHER INFORMATONHEALTH:3 FLAMMABILITY:0 REACTIVITY:0 PROTECTIVE:EHMIS INFORMATION:Page 4 of 4S-2200 self leveling underlayment