Outboard Engine DVA CHARTS - CDI Electronics

1 KEEPING YOUR BOAT ON THE WATERCut HereOutboard Engine DVA CHARTSC hrysler/ForceJohnson/EvinrudeOMC Sea DriveMercuryYamahaCDI Part # 961-0003 Rev Q2/8/2012 TECH SUPPORT rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics , Inc. is Part # 961-003 Rev Q2/8/2013 CDI Electronics (DVA) PEAK READING VOLTAGE AND RESISTANCE CHARTSNOTICE: These CHARTS were compiled using the CDI 511-9773NL Peak Adapter with a shielded Digital Multimeter.(NOTE) The resistance readings are given for a room temperature of 68 F. Higher temperatures will cause a slightly higher resistance reading. DVA readings should always be taken with everything connected with the exception of the stop CDI peak reading voltage adapter is specifically designed to work with shielded Digital Multimeters.

2 This adapter will simplify the testing of electronic ignition systems, stators, sensors and charging systems. The DVA readings will be approximately the same as any other DVA meter and the specifications listed in the service manuals can be followed without problems (Hopefully a little easier to you).The CDI piercing probe set (511-9770) and the pack load resister (511-9775) are highly recommended for use with this Plug the adapter into the shielded Digital Multimeter with the (+) rib side pin in the (V, Ohms) jack and the other pin in the (COM) Set the digital voltmeter to DC Volts (the purpose of the adapter is to convert and store the voltage so that it can be read by a meter).

3 3. Connect the probes to the component to be measured. (NOTE) The adapter will automatically compensate for polarity and all readings will be peak the following pages for readings of Chrysler, Force, Mercury, Johnson/Evinrude, OMC Sea Drive and Yamaha engines. Other ignitions can be tested using test results given by the manufacturer of the equipment or by comparing a known good system to a suspect one. Please forward any additional readings you would like to have included in future Part # 961-003 Rev Q2/8/2013 All rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics , Inc. is (Peak Reading)

4 Voltage and Resistance ChartHPYearModelorSerial#IgnitionPartNum berStatorTriggerIgnition CoilReadOhmsDVAOhmsLow SpdHigh SpdLow SpdHigh SpdLow SpdHigh *Blue to Blue680-850300-400*180-400 VOrg to GrnRed to +N/A125-140225-325* *Blue to Blue680-850300-400*180-400 VOrg to GrnRed to +N/A125-140225-325* Models525475116-5475*Blue to Blue680-850300-400*180-400 VOrg to GrnRed to +N/A125-140225-325*8198282H8J-87H8A52547 5116-5475*Blue to Blue680-850300-400*180-400 VOrg to GrnRed to +N/A125-140225-325* , B510301116-0301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator510301116-0301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator510301116-0301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator510301116-0301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator529301116-9301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator529301116-9301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator529301116-9301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & Alternator529301116-9301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to +

5 Models529301116-9301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) +N/A125-140225-325*401992-1995OE000001-O E13859918495114-4952*Blue to Blue/WhtRed to Red/Wht3250-36502200-2400*75-9028-32*180 -400V25-100 VWht/Blk to Brown, White & Purple800-14004V+ *Green/White toWhite/Green500-700400-600*180-400 VEng Gnd to Wht/Blk at CDMOpen1V+N/A800-1100501988A, B, C658475116-8475*Blue to Blue680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) +N/A125-140225-325*501988D658301116-8301 *Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) +N/A125-140225-325*501989-1992 All Models658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) +N/A125-140225-325*501992-1995OE000001-O E13859918495114-4952*Blue to Blue/WhtRed to Red/Wht3250-36502200-2400*75-9028-32*180 -400V25-100 VWht/Blk to Brown, White & Purple800-14004V+ *Green/White toWhite/Green500-700400-600*180-400 VEng Gnd to Wht/Blk at CDMOpen1V+N/A800-1100551977-1980W/Magna- power II474301-1T1 & T4 to Eng GndNot Applicable180-400 VBetween + Models475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + Models475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + Models475301116-5301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a)

6 + II474301-1T1 & T4 to Eng GndNot Applicable180-400 VBetween + *Blue to Eng GndRed to Eng Gnd3250-36502200-2400*75-9028-32*180-400 V25-100 VWht/Blk to Brown, White & Purple800-14004V+ *Blue to Eng GndRed to Eng Gnd3250-36502200-2400*75-9028-32*180-400 V25-100 VWht/Blk to Brown, White & Purple800-14004V+ *Green/White toWhite/Green500-700400-600*180-400 VEng Gnd to Wht/Blk, Wht/Yel, Blue/WhtOpen1V+N/A900-11002100-2400*8019 83-1984W/CD & Alternator475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + *Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + Models475301658301116-5301*116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + & Alternator475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + Models658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + & D332-7778114-7778*Blue to Eng GndRed to Eng Gnd3250-36502200-2400*75-9028-32*180-400 V25-100 VWht/Blk to Brown, White & Purple800-14004V+ , C & E658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a)

7 + = Black Grn = Green Pur = Purple Yel = Yellow Eng Gnd = Engine Ground N/A = Not Applicable Pri = PrimaryBrn = Brown Org = Orange Wht = White Gnd = Engine Ground COMM = Commercial Sec = Secondary* Indicates a part manufactured by CDI ElectronicsChrysler/Force2 All rights reserved. Reproduction or use of content, in any manner, without express written permission by CDI Electronics , Inc. is Part # 961-003 Rev Q2/8/2013 DVA (Peak Reading) Voltage and Resistance ChartChrysler/ForceHPYearModelorSerial#I gnitionPartNumberStatorTriggerIgnition CoilReadOhmsDVAOhmsLow SpdHigh SpdLow SpdHigh SpdLow SpdHigh SpdReadOhmsDVAPriSec901991-1995OE000001- OE138599332-777818495114-7778*114-4953*B lue to Eng GndRed to Eng Gnd3250-36502200-2400*75-9028-32*180-400 V25-100 VWht/Blk to Brown, White & Purple800-14004V+ *Green/White toWhite/Green500-700400-600*180-400 VEng Gnd to Wht/Blk, Wht/Yel.

8 Blue/WhtOpen1V+N/A900-11002100-2400*1051 976BD/BE/HA/HD/HE474301-1T1 & T4 to Eng GndNot Applicable180-400 VBetween + & Alternator475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + & T4 to Eng GndNot Applicable180-400 VBetween + , 91C658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + *Green/White toWhite/Green500-700400-600*180-400 VEng Gnd to Wht/Blk, Wht/Yel, Blue/Wht, Brn/WhtOpen1V+N/A900-11002100-2400*120 LDrive1990A, B, C658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + *Blue to Blue/Wht (LS)Red to Red/Wht (HS)3250-36502200-2400*75-9028-32*180-40 0V25-100 VBrown to Wht/BlkPurple toWhite800-14004V+ & Alternator475301116-5301*Blue to Yellow680-850300-400*180-400 VOrg to GrnRed to + Models475301658301116-5301*116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a) + & T4 to Eng GndNot Applicable180-400 VBetween + , 90C, 90D, 91A658301116-8301*Blue to Yellow (b)680-850300-400*180-400 VOrg to GrnRed to Wht/Grn (a)

9 + *Blue to Eng GndNot Appicable12V Inverter225-300 VWht/Blk to Brn, Blk, Wht, Pur & Yel800-14005V+ = Black Grn = Green Pur = Purple Yel = Yellow Eng Gnd = Engine Ground N/A = Not Applicable Pri = PrimaryBrn = Brown Org = Orange Wht = White Gnd = Engine Ground COMM = Commercial Sec = Secondary* Indicates a part manufactured by CDI Electronicsa) Some units use a White/Orange trigger lead instead of a Green ) Some Stator leads are Brown/Blue stripe instead of Blue and Brown/Yellow stripe instead of Yellow. Color Code Cross ReferenceFunctionOldNewTriggerOrangeWhit e/Orange StripeTriggerGreenWhite/Yellow StripeTriggerRedWhite/Red StripeTriggerWhite/Green StripeWhite/Green StripeStatorBlueBrown/Blue StripeStatorYellowBrown/Yellow StripePack Output to CoilOrangeOrange/BluePack Output to CoilRedBlue/RedIgnition CoilWhiteOrange/BlueStop CircuitWhiteBlack/Yellow 3 CDI Part # 961-003 Rev Q2/8/2013 All rights reserved.

10 Reproduction or use of content, in any manner, without express written permission by CDI Electronics , Inc. is (Peak Reading) Voltage and Resistance ChartHPYearModelIgnitionPartNumberStator TriggerCharge CoilPower CoilReadOhmsDVAReadOhmsDVAReadOhmsDVA4-6 01978-1988CD2582285582453582474583241113 -2285*113-2453*113-2474*113-3241*Brown to Brown/Yellow450-550150-400VN/AN/AN/AWhit e/Black to +4-551989-1993CD2 - USL584488584489 Brown to Brown/Yellow450-550150-400VN/AN/AN/AN/AN /AN/A4-551989-1993 CDI USL Replacement113-4488*113-4489*Brown to Brown/Yellow450-550150-400VN/AN/AN/AWhit e/Black to +5-501992-2006CD2W/SLOW584767584783113-4 767*113-4783*Brown to Brown/Yellow450-550150-400VN/AN/AN/AWhit e/Black to +25-501992-2005CD2W/SLOW585316113-5316*B rown to Brown/Yellow450-550150-400 VOrange to