1 SAFETY DATA SHEET . Revision Date 05/20/2015. 1. IDENTIFICATION. Product identifier . Product Name FLUID Film Aerosol (AS). Product Type Liquid, lubricant, Corrosion inhibitor Other means of identification Synonyms None Recommended use of the chemical and restrictions on use Recommended Use Corrosion inhibitor, lubricant Uses advised against No information available Details of the supplier of the SAFETY data SHEET Supplier Name Eureka Chemical Company Supplier Address 234 Lawrence Ave South San Francisco, CA 94080. US. Supplier Phone Number Phone: 650-761-3536. Fax: 650-589-1943. Contact Phone: 1-650-761-3536. Supplier Email Emergency telephone number Chemtrec (800) 424-9300.
2 2. HAZARDS IDENTIFICATION. Classification This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR ). Flammable Aerosols Category 1. GHS Label elements, including precautionary statements Emergency Overview Signal word Danger Hazard Statements Extremely flammable aerosol Appearance Straw-colored liquid Physical State Liquid spray Aerosol Odor Mild piney odor _____. Page 1 / 9. FLUID Film Aerosol (AS) Revision Date 05/20/2015. _____. Precautionary Statements - Prevention Obtain special instructions before use. Do not handle until all SAFETY precautions have been read and understood. Use personal protective equipment as required.
3 Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Pressurized container: Do not pierce or burn, even after use. Do not spray on an open flame or other ignition source. Precautionary Statements - Response IF exposed or concerned: Get medical advice/attention Precautionary Statements - Storage Protect from sunlight. Do not expose to temperatures exceeding 50 C/122 F. Precautionary Statements - Disposal Product should be disposed of via authorized waste disposal contractors in accordance with all local and national regulations. Hazards not otherwise classified (HNOC). Not applicable Unknown Toxicity No information available. Other information No information available.
4 Interactions with Other Chemicals No information available. 3. COMPOSITION/INFORMATION ON INGREDIENTS. Chemical Name CAS No Weight-% Trade Secret Refined petroleum oil, hydrotreated heavy paraffinic 64742-54-7 40 - 80 *. Petroleum gases, liquified, sweetened 68476-86-8 1 - 25 *. Calcium petroleum sulfonate 61789-86-4 1 - 10 *. *The exact percentage (concentration) of composition has been withheld as a trade secret 4. FIRST AID MEASURES. First aid measures General Advice Show this SAFETY data SHEET to the doctor in attendance. Eye Contact Rinse thoroughly with plenty of water for at least 15 minutes, also under the eyelids. If symptoms persist, call a physician.
5 Skin Contact Wipe excess material from the skin with a cloth, followed by washing with soap and water. A waterless skin cleanser is beneficial in removing the material from the skin. In the case of skin irritation or allergic reactions, see a physician. Inhalation If respiratory symptoms develop, remove to fresh air. If symptoms persist, call a physician. Ingestion Do NOT induce vomiting. Drink plenty of water. If symptoms persist, call a physician. Self-protection of the first aider Ensure that medical personnel are aware of the material(s) involved. _____. Page 2 / 9. FLUID Film Aerosol (AS) Revision Date 05/20/2015. _____. Most important symptoms and effects, both acute and delayed Most Important Symptoms and No information available.
6 Effects Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES. Suitable Extinguishing Media Dry chemical. Carbon dioxide (CO2). Foam. Unsuitable Extinguishing Media DO NOT EXTINGUISH A LEAKING GAS FIRE UNLESS LEAK CAN BE STOPPED. Specific Hazards Arising from the Chemical Some may burn but none ignite readily. Ruptured cylinders may rocket. Uniform Fire Code Aerosols: Level III. Hazardous Combustion Products Carbon oxides. Explosion Data Sensitivity to Mechanical Impact No. Sensitivity to Static Discharge Yes. Protective equipment and precautions for firefighters Move containers from fire area if you can do it without risk.
7 Damaged cylinders should be handled only by specialists. 6. ACCIDENTAL RELEASE MEASURES. Personal precautions, protective equipment and emergency procedures Personal Precautions Stop leak if you can do it without risk. Other Information Ventilate the area. Environmental Precautions Environmental Precautions Prevent entry into waterways, sewers, basements or confined areas. Methods and material for containment and cleaning up Methods for Containment Prevent further leakage or spillage if safe to do so. Methods for cleaning up Soak up with inert absorbent material. Pick up and transfer to properly labeled containers. _____. Page 3 / 9. FLUID Film Aerosol (AS) Revision Date 05/20/2015.
8 _____. 7. HANDLING AND STORAGE. Precautions for safe handling Handling Handle in accordance with good industrial hygiene and SAFETY practice. Do not puncture or incinerate cans. Contents under pressure. Avoid breathing vapors or mists. Avoid contact with eyes. Keep away from open flames, hot surfaces and sources of ignition. Conditions for safe storage, including any incompatibilities Storage Keep containers tightly closed in a dry, cool and well-ventilated place. Protect from sunlight. Keep away from heat, sparks, flame and other sources of ignition ( , pilot lights, electric motors and static electricity). Keep in properly labeled containers.
9 Do not store near combustible materials. Keep in an area equipped with sprinklers. Incompatible Products None known based on information supplied. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION. Control parameters Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH. Refined petroleum oil, hydrotreated heavy TWA: 5 mg/m3, as oil mist, TWA: 5 mg/m3, as oil mist, paraffinic mineral mineral 64742-54-7 STEL: TWA: 10 mg/m3, as oil mist, mineral ACGIH TLV: American Conference of Governmental Industrial Hygienists - Threshold Limit Value OSHA PEL: Occupational SAFETY and Health Administration - Permissible Exposure Limits NIOSH IDLH Immediately Dangerous to Life or Health Other Exposure Guidelines Vacated limits revoked by the Court of Appeals decision in AFL-CIO v.
10 OSHA, 965 962 (11th Cir., 1992) See section 15 for national exposure control parameters Appropriate engineering controls Engineering Measures Showers Eyewash stations Ventilation systems Individual protection measures, such as personal protective equipment Eye/Face Protection No special protective equipment required. Use chemical eye goggles in tanks and confined spaces. Skin and Body Protection Wear protective gloves and protective clothing. Respiratory Protection No protective equipment is needed under normal use conditions. Use approved respirator with organic vapor cartridges in tanks and confined spaces. If exposure limits are exceeded or irritation is experienced, ventilation and evacuation may be required.