SAFETY DATA SHEET Page: 1 Klean-Strip Aircraft Paint ...

1 03/11/2016 Revision:03/14/2016 Printed:Page: 1 klean -Strip Aircraft Paint RemoverSAFETY data SHEET08/06/2015 Supersedes Revision: Klean-Strip Aircraft Paint RemoverProduct Name:W. M. BarrCompany Name:2105 Channel AvenueMemphis, TN 381133E 24 Hour Emergency ContactEmergency Contact:(800) Barr Customer ServiceInformation:(800)398-3892(901)775 -0100 Phone Number:Remove a wide range of finishes from the metal surfaces of automobiles, trucks andcyclesIntended site address:GAR343, QAR343, GDX586 Product Code:1. PRODUCT AND COMPANY IDENTIFICATIONThis product is regulated by the United States Consumer Product SAFETY Commissionand is subject to certain labeling requirements under the Federal Hazardous SubstancesAct. These requirements differ from the classification criteria and hazard informationrequired for SAFETY data sheets (SDS). The product label also includes other importantinformation, including directions for use, and should always be read in its entirety prior tousing the Information2.

2 HAZARDS IDENTIFICATIONP201: Obtain special instructions before : Do not handle until all SAFETY precautions have been read and : Do not breathe gas/mist/ : Wash hands thoroughly after : Do not eat, drink or smoke when using this : Use only outdoors or in a well-ventilated : Wear protective gloves/protective clothing/eye protection/face Precaution Phrases:P301+312: IF SWALLOWED: Call a POISON CENTER or doctor/physician if you +361+353: IF ON SKIN (or hair): Remove/take off immediately all contaminatedclothing. Rinse skin with +340: IF INHALED: Remove victim to fresh air and keep at rest in a positioncomfortable for +351+338: IF IN EYES: Rinse cautiously with water for several minutes. Removecontact lenses, if present and easy to do. Continue Response Phrases:H302: Harmful if : Causes severe skin burns and eye : Causes serious eye : Harmful if : May cause : Causes damage to Hazard Phrases:Acute Toxicity: Oral, Category 4 Acute Toxicity: Inhalation, Category 4 Skin Corrosion/Irritation, Category 1 ASerious Eye Damage/Eye Irritation, Category 1 Carcinogenicity, Category 1 BSpecific Target Organ Toxicity (single exposure), Category 1 DangerGHS Signal Word:Licensed to Barr and CompanyGHS format03/11/2016 Revision:03/14/2016 Printed:Page: 2 Klean-Strip Aircraft Paint RemoverSAFETY data SHEET08/06/2015 Supersedes Revision:P307+311: IF exposed: Call a POISON CENTER or +313: IF exposed or concerned: Get medical : Immediately call a POISON CENTER or : Specific treatment see : Rinse : Wash contaminated clothing before : Store locked : Dispose of contents/container according to local, state and federal Storage and DisposalPhrases:Hazard Rating System.

3 BilitySpecal HazardHealthFlammaHEALTHFLAMMABILITYPPEP HYSICAL301*XNFPA:HMIS:This material is classified as hazardous under OSHA Regulatory Status:Inhalation Acute Exposure Effects:Vapor harmful. May cause dizziness; headache; watering of eyes; injuries to mucousmembranes; irritation of the throat and respiratory tract; nausea; numbness in fingers,arms and legs; bronchospasm; hot flashes; tissue damage; spotted vision; dilation ofpupils; increase of carboxyhemoglobin levels, which can cause stress to thecardiovascular system; arm, leg, and chest pains; depression of the central nervoussystem; bronchitis; pulmonary edema; chemical pneumonitis; difficulty breathing;vomiting; visual disturbances; giddiness; intoxication; sleepiness; cough and dyspnea;cold, clammy, extremities, and diarrhea. Severe overexposure may cause irregular orrapid heartbeat; convulsions; unconsciousness; and death. Elevatedcarboxyhemoglobin levels can be additive to the increase caused by smoking and othercarbon monoxide Contact Acute Exposure EffectsMay be absorbed through the skin.

4 May cause irritation; burns; blisters; tissuedestruction; drying and defatting of skin; and dermatitis. May cause symptoms listedunder inhalation. Vapors and mist can irritate moist Contact Acute Exposure EffectsMay cause irritation and pain; conjunctivitis of eyes; corneal ulcerations of the eye;burns; and blindness. Vapors and mist can irritate Acute Exposure EffectsPoison. Cannot be made non-poisonous. May be fatal or cause blindness. May causeirritation to mouth, throat and stomach; headache; nausea; dizziness; stupor; liver,kidney and heart damage; depression of the central nervous system; narcosis; burning ofesophagus, stomach, mouth and throat; vomiting; gastrointestinal irritation; diarrhea;abdominal pain; collapse; and death. May be corrosive to mouth and throat. Mayproduce symptoms listed under inhalation. Liquid aspirated into lungs may causechemical pneumonitis and systemic Exposure EffectsReports have associated repeated and prolonged overexposure to solvents withneurological and other physiological damage.

5 Prolonged or repeated contact may causedermatitis. Prolonged skin contact may result in absorption of a harmful amount of thismaterial. May cause headache; conjunctivitis; gastric disturbances; skin irritation;permanent central nervous system changes; decreased response to visual and auditorystimulation; visual impairment or blindness; hallucinations; changes in blood; bloodPotential Health Effects(Acute and Chronic):Licensed to Barr and CompanyGHS format03/11/2016 Revision:03/14/2016 Printed:Page: 3 Klean-Strip Aircraft Paint RemoverSAFETY data SHEET08/06/2015 Supersedes Revision:Diseases of the blood; skin; eyes; liver; kidneys; lungs; cardiovascular; pulmonary; andrespiratory systems; alcoholism; and rhythm disorders of the Conditions GenerallyAggravated By Exposure:disorders; kidney, liver or pancreatic damage; insomnia; giddiness; and death. Maycause additional symptoms listed under #Hazardous Components (Chemical Name)3. COMPOSITION/INFORMATION ON INGREDIENTSC oncentration 75-09-2 Dichloromethane {Methylene chloride; R-30;Freon 30} % 67-56-1 Methanol {Methyl alcohol; Carbinol; Woodalcohol} % 1336-21-6 Ammonium hydroxide {Ammonia aqua;Ammonium liquor}< % 1330-20-7 Xylene (mixed isomers) {Benzene, dimethyl-}< % 64742-47-8 Hydrotreated light distillate (petroleum)< % 68132-50-3 Fatty acid soap< % 100-41-4 Ethylbenzene {Ethylbenzol; Phenylethane}< %Specific percentage of composition is being withheld as a trade ChemicalInformation4.

6 FIRST AID MEASURESSkin:Immediately begin washing the skin thoroughly with large amounts of water and mildsoap, if available, while removing contaminated clothing. Seek medical attention ifirritation :Immediately begin to flush eyes with water, remove any contact lens. Continue to flushthe eyes for at least 15 minutes, then seek immediate medical :Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult,give oxygen. Get immediate medical :If swallowed, do NOT induce vomiting. Seek immediate medical attention. Call aphysician, hospital emergency room, or poison control center immediately. Never giveanything by mouth to an unconscious and First AidProcedures:Poison. This product contains methylene chloride and product contains methanol which can cause intoxication and central nervous systemdepression. Methanol is metabolized to formic acid and formaldehyde. Thesemetabolites can cause metabolic acidosis, visual disturbances and blindness.

7 Sincemetabolism is required for these toxic symptoms, their onset may be delayed from 6 to30 hours following ingestion. Ethanol competes for the same metabolic pathway andhas been used to prevent methanol metabolism. Ethanol administration is indicated insymptomatic patients or at blood methanol concentrations above 20 ug/dl. Methanol iseffectively removed by hemodialysis. Adrenalin should never be given to a personoverexposed to methylene to Physician:See Potential Health and Symptoms OfExposure:Licensed to Barr and CompanyGHS format03/11/2016 Revision:03/14/2016 Printed:Page: 4 Klean-Strip Aircraft Paint RemoverSAFETY data SHEET08/06/2015 Supersedes Revision:This material sensitizes the heart to the effects of sympathomimetic and other sympathomimetic drugs may initiate cardiac arrhythmias inindividuals exposed to this material. This material is metabolized to carbon , elevations in carboxyhemoglobin as high as 50% have been reported,and levels may continue to rise for several hours after exposure has ceased.

8 data inexperimental animals suggest there is a narrow margin between concentrations causinganesthesia and FIRE FIGHTING MEASURESF lash Pt:No respiratory protection should be provided for fire fighters fighting fires inbuildings or confined areas. Storage containers exposed to fire should be kept cool withwater spray to prevent pressure build-up. Stay away from heads of containers that havebeen exposed to intense heat or of liquid or vapor with flame or hot surfaces will produce toxic gases and acorrosive residue that will cause deterioration of Fighting Instructions:Flashpoint: NO FLASH TO BOILINGF lammable Properties andHazards:Autoignition Pt:No Limits:LEL: No data . UEL: No carbon dioxide, dry powder or Extinguishing Media:6. ACCIDENTAL RELEASE MEASURESC lean-upKeep unnecessary people away; isolate hazard area and deny entry. Stay upwind, outof low areas, and ventilate closed spaces before entering. Shut off ignition sources;keep flares, smoking or flames out of hazard SpillsTake up liquid with sand, earth or other noncombustible absorbent material and place ina plastic container where SpillsDike far ahead of spill for later DisposalDispose in accordance with applicable local, state and federal To Be Taken In CaseMaterial Is Released OrSpilled:7.

9 HANDLING AND STORAGERead carefully all cautions and directions on product label before use. Since emptycontainer retains residue, follow all label warnings even after container is of empty container according to all regulations. Do not reuse this protective clothing and take precautions to prevent all skin and eye To Be Taken inHandling:Store in a cool, dry place. Exposure to high temperatures or prolonged exposure to sunmay cause can to leak or swell. Once opened, remover should be used within sixmonths or discarded to avoid can deterioration. Do not store near flames or at elevatedPrecautions To Be Taken inStoring:Licensed to Barr and CompanyGHS format03/11/2016 Revision:03/14/2016 Printed:Page: 5 Klean-Strip Aircraft Paint RemoverSAFETY data SHEET08/06/2015 Supersedes EXPOSURE CONTROLS/PERSONAL PROTECTIONOSHA TWAACGIH TWACAS #Partial Chemical NameOther LimitsPEL: 25 ppmSTEL: 125 ppm (15 min)TLV: 50 ppm 75-09-2 Dichloromethane {Methylene chloride;R-30; Freon 30}No : 200 ppmTLV: 200 ppmSTEL: 250 ppm 67-56-1 Methanol {Methyl alcohol; Carbinol;Wood alcohol}No data .

10 1336-21-6 Ammonium hydroxide {Ammonia aqua;Ammonium liquor}No : 100 ppmTLV: 100 ppmSTEL: 150 ppm 1330-20-7 Xylene (mixed isomers) {Benzene,dimethyl-}No : 200 mg/m3 64742-47-8 Hydrotreated light distillate (petroleum)No data . 68132-50-3 Fatty acid soapNo : 100 ppmTLV: 100 ppmSTEL: 125 ppm 100-41-4 Ethylbenzene {Ethylbenzol;Phenylethane}No OSHA controlled work place and other regular users. Use only with adequateventilation under engineered air control systems designed to prevent exceedingappropriate TLV. For occasional use, where engineered air control is not feasible, useproperly maintained and properly fitted NIOSH approved self-contained breathingapparatus for chlorinated solvent vapors. A dust mask does not provide protectionagainst Equipment(Specify Type): SAFETY glasses, chemical goggles, or face shields are recommended to safeguardagainst potential eye contact, irritation, or injury. Chemical goggles or face shields arerecommended when splashing or spraying of chemical is possible.