Example: confidence

Service Schedule – Passenger Vehicles - Volkswagen

Service Schedule Passenger Vehicles Job Order No Date Vehicle Model Odometer VIN Dealer Stamp 15K 30K 60K 105K OK NOT OK RECTIFIED. All external lights - Check function: park lights, dipped beam, main beam, fog lights, turn signals, hazard warning X X X X lights, cornering lights, brake lights (including 3rd brake light), tail lights, reversing lights, rear fog light, number n n n plate light, turn signals, hazard warning lights Interior equipment: luggage and glove compartment lights, cigarette lighter/12 V sockets, warning lamps, horn: X X X X n n n check function Windscreen wash/wiper system and headlight washer system if fitted.

15K 30K 60K 105K OK NOT OK RECTIFIED X X X X All external lights - Check function: park lights, dipped beam, main beam, fog lights, turn signals, hazard warning

Information

Domain:

Source:

Link to this page:

Please notify us if you found a problem with this document:

Other abuse

Transcription of Service Schedule – Passenger Vehicles - Volkswagen

1 Service Schedule Passenger Vehicles Job Order No Date Vehicle Model Odometer VIN Dealer Stamp 15K 30K 60K 105K OK NOT OK RECTIFIED. All external lights - Check function: park lights, dipped beam, main beam, fog lights, turn signals, hazard warning X X X X lights, cornering lights, brake lights (including 3rd brake light), tail lights, reversing lights, rear fog light, number n n n plate light, turn signals, hazard warning lights Interior equipment: luggage and glove compartment lights, cigarette lighter/12 V sockets, warning lamps, horn: X X X X n n n check function Windscreen wash/wiper system and headlight washer system if fitted.

2 Check function, park position, spray jet X X X X n n n settings and for damage, adjust if necessary X X X X Windscreen: Perform visual check for damage n n n Reset Service interval display using VGA approved diagnostic tester and interrogate fault memories and attach X X X X n n n print out to job card X X X X Engine and components in engine compartment (from above): Perform visual check for leaks and damage n n n X X X X Check battery using VGA approved battery tester and attach print out to job card n n n X X X X Windscreen wash/wipe system: Check fluid level, Replenish n n n X X X X Cooling system: Check concentration and coolant level and record anti-freeze value n n n X X X X Brake system: Check master cylinder for leaks, top up if required n n n X X X X Power steering.

3 Check fluid level if applicable and top up as necessary n n n X X X X Check plenum chamber and water drain valves and clean if necessary n n n X X X X Tyre pressure of all wheels including spare: Check and adjust n n n X X X X Check mobility set expiry date: Renew if necessary n n n X X X X Tyres: Check condition and wear and record tread depths FL FR RR RL Spare n n n X X X X Check brake pad/lining and record thickness: Front Rear n n n X X X X Check brake disc/drum and record thickness: Front Rear n n n X X X X Handbrake: Adjust if required as per ElsaPro instructions n n n X X X X Engine oil: Drain, Renew oil filter n n n X Transmission and differential: check level and top up if necessary n n n X X X X Engine, Transmission, final drive, Haldex and drive shaft bellows: Visual check for leaks and damage n n n X X X X Ball joints, control arms, axle bearings and anti-roll bar rubber mounting: Perform visual check for damage n n n X X X X Track rod ends.

4 Check play, security and boots n n n X X X X Brake system and shock absorbers: Perform visual check for leaks and damage n n n X X X X Exhaust system: Visual check for leaks, security and damage n n n X X X X Underbody: Visual check for damage to underbody sealant, underbody panels, routing of lines, plugs n n n X X X X Front and rear coil springs and rubber buffers: Perform visual check for damage n n n X Fuel Filter: Renew (excluding internal tank filters) n n n X X X X Engine oil: Replenish n n n X Spark Plugs: Renew n n n X X X X Door locks, hinges and check straps: Lubricate and check tightness of hinges and check straps n n n X X X X Vehicles equipped with sunroof: Check operation, clean and lubricate guide rails and clean drains n n n X X X X Vehicles with convertible roof: check operation.

5 Clean and lubricate seals n n n X X X X Headlight adjustment: Check, if necessary adjust n n n X X X X Your next services sticker: Enter and attach Service sticker and fill out Service book n n n X X X X Carry out a road test n n n ADDITIONAL REQUIREMENTS. X X X X Volkswagen approved fuel additive (petrol Vehicles only) n n n Brake fluid (clutch fluid if applicable): Renew 24 months n n n Pollen Filter: Renew every 24 months n n n Air filter: Renew 45,000km n n n Renew rubber buffer for air filter housing if housing removed, Engine codes CDLC, CDLG n n n Haldex oil: Renew every 3 years (MY10 onwards) n n n VGASSPVO8 2014 Volkswagen Group Australia Pty.

6 Ltd. 02/14 V9. Front Differential Lock (Golf GTI Performance) Renew Haldex oil every 3 years n n n X Haldex oil and filter: Renew (up to and including MY09) n n n X 6 speed DSG gearbox: Renew oil and oil filter n n n X 7 speed DSG Tiguan: Renew oil n n n Toothed belt: Inspect belt at 90,000km n n n X Toothed belt: Renew toothed belt, tensioner and roller 7 years or 105,000km n n n X X X X Touareg lubricate control rod actuator on turbochargers V10 only n n n Touareg: Renew differential oils front and rear 90,000km n n n Touareg: DPF additive container: Extract and replenish additive 90,000km / 48 months if fitted (V10 with DPF) n n n Touareg: Particulate filter renewed V10 only 120,000km n n n Touareg.

7 Renew gates coupling and freewheel for alternator and air conditioning drive 180,000km n n n Vehicles fitted with tyre pressure monitoring renew tyre pressure sensors 72 months n n n Check DPF ash mass specification for engine type at 150,000km and then every 30,000km n n n I hereby certify that the above items have been I hereby certify that this vehicle has been correctly Notes inspected for correct installation, operation and checked for Customer delivery and all paper work has adjustment. been completed in full.

8 Service Technician Quality Control Name Name Date Date Distribution: WHITE: Customer's copy BLUE: Dealer's copy


Related search queries