Technical Service Information - ATSG

1 FORD/INTERNATIONAL MEDIUM TRUCK 5R110W LCF SERIES MANUAL DIAGNOSTIC CODE RETRIEVAL PROCEDUREFord/International Medium Truck LCF series, equipped with the 5R110W transmission, are capable of Diagnostic Trouble code retrieval thru a manual process that does not require a scan tool. Refer to the Information below for this procedure and the following pages for Diagnostic Trouble Code descriptions for both the manual process and the scan 1:Place vehicle on a level surface and use wheel chocksto prevent vehicle from 2:Turn ignition ON DO NOT start 3:Place Shift Selector in 2 Position (See Figure 1)Step 4:Press Tow/Haul switch 4 times within 4 seconds, this willinitiate Manual Code retrieval.

2 (See Figure 1)manual code retrieval initiationreading codesThe Check Trans, Trans Temp and Tow/Haulall turn ON simultaneously to indicate diagnosticmode has been entered. (See Figure 2)Step 5:The Check Trans and Trans Temp turn OFFand the Tow/Haul remains 6:Flash formatThe Check Trans will communicate each digitof the fault codes by flashing. Example: 1 Flash-pause-1 Flash-pause 1 Flash= DTC 111 DTC 111= No Codes more than one fault code is present the Trans Temp will illuminate between each fault all Fault Codes have been Flashed, the Trans Tempindicator will Flash twice and the Tow Haul will go timesSpecial thanks toChris LenoxCamerota Truck PartsEnfield, CTTechnical Service InformationAUTOMATIC TRANSMISSION Service GROUP12-42 Page 1 of 7clearing codes after repairsTurn ignition ON but do not start 1:Place shift selector in D position and push the TOW/Haulswitch 2:Place shift selector in N position and push the TOW/Haulswitch 3:Place shift selector in R position and push the TOW/Haulswitch 4.

3 Place shift selector in P position and push the TOW/Haulswitch 5:The Check Trans Trans Temp and Tow/Haulwill flash three times to indicate diagnosticmode has been timesAUTOMATIC TRANSMISSION Service GROUPT echnical Service Information12-42 Page 2 of TRIPTOWPRN321 DFigure 1 INDICATOR LAMP LOCATIONSF igure 2 TOW HAUL SWITCH LOCATIONC opyright 2012 ATSGAUTOMATIC TRANSMISSION Service GROUPT echnical Service InformationCopyright 2012 ATSG12-42 Page 3 of 75R110W Diagnostic Trouble Code ChartOBDllDTCP0706P0707P0708P0711P0712P0 710P0713P0710P0715P0717P0718P0720P0721P0 722P0730P0740P0741P1711P1783P1702P1705 Transmission Range sensor signal out of range or duty cycle is below threshold, sensor/circuit elect.

4 Range sensor signal duty cycle is above threshold, sensor/circuit elect. Range sensor circuit failure, or KOEO or KOER not run in P or N has detected no TFT change during operation. Stuck at some normal drop across TFT sensor exceeds scale set for temperature of 315 drop across TFT sensor exceeds scale set for temperature of minus 40 not operating at normal temperature during On-Board over temp condition detected a loss of TSS signal during normal detected a loss of OSS signal during normal has detected a noisy TSS has detected a noisy OSS has not detected a TSS has detected no OSS has detected a gear ratio Solenoid, Electrical, Open slippage detected during or Hydraulic Trouble Code DescriptionDiagnostic CodeDescription/SymptomTransmission Range(TR-P) SensorTransmission Range(TR-P) SensorTransmission Range(TR-P)

5 SensorTrans Fluid Temp(TFT) SensorTrans Fluid Temp(TFT) SensorTrans Fluid Temp(TFT) SensorTrans Fluid Temp(TFT) SensorTrans Fluid Temp(TFT) SensorTurbine Shaft Speed(TSS) SensorTurbine Shaft Speed(TSS) SensorTurbine Shaft Speed(TSS) SensorOutput Shaft Speed(OSS) SensorOutput Shaft Speed(OSS) SensorOutput Shaft Speed(OSS) SensorClutch Control Solenoidor Internal ProblemTCC SolenoidTCC SolenoidFlashDTC115113114412413122123121 124121414423125131132133134136141142143 AUTOMATIC TRANSMISSION Service GROUPT echnical Service InformationCopyright 2012 ATSG12-42 Page 4 of 75R110W Diagnostic Trouble Code ChartP0742P0743P0744P0748P0960P0962P0963 P0750P0751P0752P0753P0973P0974P0755P0756 P0757P1744 TCC Solenoid circuit, shorted to Solenoid circuit, shorted to Solenoid circuit, shorted to Solenoid circuit, shorted to Solenoid circuit, shorted to Solenoid circuit.

6 Shorted to Solenoid circuit slippage detected during or Hydraulic Solenoid circuit Solenoid circuit open Solenoid circuit open Solenoid circuit, or solenoid failure Solenoid circuit, or solenoid failure Solenoid circuit, or solenoid failure Solenoid circuit, or solenoid failure Solenoid circuit Solenoid circuit open SolenoidTCC SolenoidTCC SolenoidTCC SolenoidLine Pressure Control(PC-A) SolenoidLine Pressure Control(PC-A) SolenoidLine Pressure Control(PC-A) SolenoidLine Pressure Control(PC-A) SolenoidSSPC-A Solenoid(Coast Clutch)SSPC-A Solenoid(Coast Clutch)SSPC-A Solenoid(Coast Clutch)SSPC-A Solenoid(Coast Clutch)SSPC-A Solenoid(Coast Clutch)SSPC-A Solenoid(Coast Clutch)SSPC-B Solenoid(Overdrive Clutch)SSPC-B Solenoid(Overdrive Clutch)SSPC-B Solenoid(Overdrive Clutch)

7 OBDllDTCD iagnostic Trouble Code DescriptionDiagnostic CodeDescription/SymptomFlashDTC144145151 4211523143153211531541552113233242122132 14 AUTOMATIC TRANSMISSION Service GROUPT echnical Service InformationCopyright 2012 ATSG12-42 Page 5 of 75R110W Diagnostic Trouble Code ChartP0758P0976P0977P0760P0761P0762P0763 P0979P0980P0982P0983P0765P0766P0767 SSPC-B Solenoid, or shorted to Solenoid, or shorted to Solenoid, or circuit shorted to Solenoid, or circuit shorted to Solenoid, or circuit shorted to Solenoid, or circuit shorted to Solenoid circuit Solenoid circuit open Solenoid circuit, or solenoid failure Solenoid circuit, electrical Solenoid circuit, or solenoid failure Solenoid circuit, or solenoid failure Solenoid circuit, or solenoid failure Solenoid circuit open Solenoid(Overdrive Clutch)SSPC-B Solenoid(Overdrive Clutch)SSPC-B Solenoid(Overdrive Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-C Solenoid(Intermediate Clutch)SSPC-D Solenoid(Direct Clutch)SSPC-D Solenoid(Direct Clutch)SSPC-D Solenoid(Direct Clutch)SSPC-D Solenoid(Direct Clutch)SSPC-D Solenoid(Direct Clutch)

8 OBDllDTCD iagnostic Trouble Code DescriptionDiagnostic CodeDescription/SymptomFlashDTC215331332 221222223224334336225231232P0768 SSPC-D Solenoid electrical Solenoid(Direct Clutch)233342343 AUTOMATIC TRANSMISSION Service GROUPT echnical Service InformationCopyright 2012 ATSG12-42 Page 6 of 7P0985P0986P0791P0793P0794 SSPC-E Solenoid, or circuit shorted to Solenoid, or circuit shorted to input from input from signal Solenoid(Low/Reverse Clutch)SSPC-E Solenoid(Low/Reverse Clutch)Intermediate ShaftSpeed Sensor (ISS)Intermediate ShaftSpeed Sensor (ISS)Intermediate ShaftSpeed Sensor (ISS)P1780 Transmission Control Switch voltage ControlSwitch (TCS)U0100 Transmission Control Module loss of Communicationwith the Engine Control Module thru Control ControlModule (CAN) Control Area NetworkOBDllDTCD iagnostic Trouble Code DescriptionDiagnostic CodeDescription/SymptomFlashDTC5R110W Diagnostic Trouble Code Chart345351243244245422435 AUTOMATIC TRANSMISSION Service GROUPT echnical Service InformationCopyright 2012 ATSG12-42 Page 7 of 7