TM 10-3930-638-10 - Liberated Manuals.com

1 PAGE iPAGE 1-1 PAGE 1-3 PAGE 1-5 PAGE 2-1 PAGE 2-9 PAGE 2-13 PAGE2-21 PAGE 3-1 PAGE 3-3 PAGE A-1 PAGE B-1 PAGE C-1 PAGE D-1TM 10-3930-638-10 OPERATOR S MANUALTRUCK, FORKLlFT, DED,PNEUMATIC TIRE, ARTICULATEDFRAME STEER, 4,000 LB. CAPACITYROUGH TERRAIN, ARMY MODEL MHE 237(J. I. CASE MODEL M4K)(NSN 3930 -01-076-4237)HEADQUARTERS, DEPARTMENT OF THE ARMYMAY 1980TM 10-3930-638-10 Change 3 AWARNINGFIRE HAZARDD iesel fuel used in operation of this equipment is combustibleWARNINGHYDRAULIC OIL UNDER PRESSURE2,500 PSI pressure is used in the operation of this SHOCK HAZARDA lways disconnect battery ground cable before working on electrical components of this equip-ment.

2 WARNINGTIRE INFLATIONO bserve caution when inflating tires. Make sure tires are properly seated on rims before inflating. Improperly seated tires can burst with explosive force sufficient to cause CHEMICALSB attery electrolyte is toxic and corrosive! Use protective goggles and gloves. Avoid contact with skin, eyes, clothes, and do not breathe GASES CAN BE DEADLYE xhaust gases can produce symptoms of headache, dizziness, loss of muscular control, or coma. Permanent brain damage or death can result from severe exposure. You can ensure your safety by following these rules:DO NOT operate the heater or engine in an enclosed area unless it is properly NOT drive with any of the truck s inspection plates, cover plates, or the hood off unless neces-sary for maintenance.

3 If you notice exhaust odors or exposure symptoms, IMMEDIATELY VEN-TILATE the area. If the symptoms persist, remove the affected people and treat them: Expose them to fresh air. If necessary, give artificial respiration. Keep them warm. DO NOT permit physical to FM 21-11, First Aid for Soldiers, for first aid treatment of injured HAZARDN oise level exceeds 85 dB(A) at three feet in front, 15 feet at side, and 24 feet at rear of personnel shall wear a hearing protection device when operating the 10-3930-638-10 BChange 3 WARNINGBe sure your seat belt is fastened before starting engine and operating the vehicle.

4 WARNINGBe sure that steering bypass valve is closed (fully clockwise) and that shipping lock pin is removed before operating vehicle. Failure to do so will cause loss of steering control, which may result in death or serious operate vehicle at a safe speed. Avoid overloading and sudden stops. Caution is advised when operating on a slope with any load. Do not tilt load out beyond vertical position of mast when elevated unless load is over a fluid is toxic and highly flammable. Container is pressurized to act as an expellent. Do not heat container and do not discharge starting fluid in confined areas or near an open flame.

5 Do not discard used container in an open cleaning solvent P-D-680 used to clean parts is potentially dangerous to personnel and prop-erty. Do not use near open flame or excessive heat. Flash point of solvent is 138 degrees EXPOSUREIf NBC exposure is suspected, personnel wearing protective equipment must handle all air cleaner media. Consult your NBC Officer or NBC NCO for appropriate handling or disposal to FM 3-3, Chemical and Biological Contamination Avoidance, FM 3-5, NBC Decontamina-tion, FM 3-3-1, Nuclear Contamination contaminated filters must be handled using adequate precautions and must be disposed of by trained order this NBC decal use.

6 National Stock Number (NSN) - 7690-01-114-3702 Part Number (PN) - 12296626 Commercial and Government Entity Code (CAGEC) - 19207 WARNINGIF NBC EXPOSURE IS SUSPECTED ALL AIRFILTER MEDIA WILL BE HANDLED BY PER-SONNEL WEARING FULL NBC PROTEC-TIVE EQUIPMENT. SEE OPERATOR/MAINTENANCE 10- 3930 -638-10C3 Approved for public release; distribution is 3 DEPARTMENT OF THE ARMYW ashington , 15 July 2008 OPERATOR S MANUALTRUCK, FORKLIFT, DED, PNEUMATIC TIRE,ARTICULATED FRAME STEER,4,000-LB CAPACITY, ROUGH TERRAINARMY MODEL MME 237( CASE MODEL M4K)(NSN 3930 -01-076-4237)TM 10-3930-638-10 , dated 30 May 1980, is changed as old pages and insert new or changed material is indicated by a vertical bar in the margin of the page and by a vertical bar adja-cent to the PagesInsert PagesA and BA and Bi and 1-0i and 1-01-1 thru 1-61-1 thru 1-62-5 thru 2-82-5 thru and ( blank) ( blank)

7 2-11 thru 2-142-11 thru 2-142-17 thru 2-202-17 thru 2-203-3 and 3-43-3 and and thru 3-123-5 thru 3-12 Index 1 and Index 2 Index 1 and Index 22028 Sample2028 this change sheet in front of the publication for reference 10- 3930 -638-10C3By Order of the Secretary of the Army:GEORGE W. CASEY, , United States ArmyChief of StaffOfficial:DISTRIBUTION: To be distributed in accordance with the initial distribution requirements for IDN: 252161, require-ments for TM 10- 3930 -638-10C2 CHANGENo. 2 HEADQUARTERSDEPARTMENT OF THE ARMYW ashington D. C., 4 December 1990 OPERATOR S MANUALTRUCK, FORKLIFT, DED, PNEUMATIC TIRE,ARTICULATED FRAME STEER,4,000-LB.

8 CAPACITY, ROUGH TERRAINARMY MODEL MHE 237(NSN 3930 -01-076-4237)TM 10-3930-638-10 , 30 May 1980, is changed as follows:1. Remove old pages and insert new New or changed material is indicated by a vertical bar in the margin of the page and by a vertical bar adja-cent to the TA PagesInsert Pages1-9 and 1-101-9 and 1-102-9 through 2-122-9 through 2-123. File this change sheet in front of the publication for reference Order of the Secretary of the Army:CARL E. VUONOG eneral, United States ArmyChief of StaffOfficial:THOMAS F.

9 SIKORAB rigadier General, United States ArmyThe Adjutant GeneralDistribution:TO be distributed in accordance with DA Form 12-25-E (Block 2161) Operator maintenance require-ments for TM10- 3930 -638-10. A B i 1-0 1-1 1-2 1-7 2-9 2-12 2-17 2-18 A-1(A-2 blank) C-1(C-2 blank) D-1(D-2 blank)TM 10-3930-638-10 Change 3A/(B Blank)LIST OF EFFECTIVE PAGESDate of issue for original manual is:Original .. 30 March 1980 Change 1 .. 14 March 1990 Change 2 .. 4 December 1990 Change 3 .. 15 July 2008 Total number of pages for front and rear matter is 40and total number of pages is 418 consisting of the following: PageNo.

10 * * Page0A and B3 Back Cover0i 31-001-1 to 1-531-6 and 1-701-811-921-1012-1 to 2-402-5 to and ( Blank)32-1102-12 and ( Blank)32-14 to 2-1702-1832-1902-2032-21 and 2-2203-1 to ( Blank)33-5 to 3-1233-13 to 3-15/(3-16 Blank)0A-1/(A-2 Blank)1B-1 and B-20C-1/(C-2 Blank)1D-1/(D-2 Blank)1 Index-1 and Index-23* Zero in this column indicates an original page or work 10-3930-638-10 Change 3iTECHNICAL MANUALHEADQUARTERSDEPARTMENT OF THE ARMYW ashington, , 30 May 1980 OPERATOR S MANUALTRUCK, FORKLIFT, DED, PNEUMATIC TIRE, ARTICULATED FRAME STEER,4,000-LB.