p92-6083, HARNESS- ENGINE, CUM ISX PB387 - …

1 TABLE AFUTURE USEVAROMIT CIRCUITSOMIT ITEM NUMBERSUSAGE0---TABLE BJ1939 DATA LINKVAROMIT CIRCUITSOMIT ITEM NUMBERSUSAGE1660-0, 661-0, 662-0,660-1, 661-1, 662-1,660-2, 661-2, 662-2,660-3, 660-4, 660-5,660-6 J43, P5, R1, S20, S21, S22,S25, S26, S27 WITHOUTJ1939 DATA LINK2 NONENONEWITHJ1939 DATA LINKTABLE CDUAL STATION CONTROLSVAROMIT CIRCUITSOMIT ITEM NUMBERSUSAGE1EE02-4, EE03-2, EE18-1, EE39-1, EE58-1, EE63-1, EE64-1, 239-2 J60, P51, AND S28 WITHOUTDUAL STATIONCONTROLS2 NONENONEWITHDUAL STATIONCONTROLSP3 LABEL: ENGINE ECUCKT RING_TERMINALBLACK_PVC_SHRINK_TUBE_TERM_ INSULATION1T3 RING_TERMINALBLACK_PVC_SHRINK_TUBE_TERM_ INSULATION1T2 RING_TERMINALBLACK_PVC_SHRINK_TUBE_TERM_ INSULATION1T1 RING_TERMINALRED_PVC_SHRINK_TUBE_TERMINA L_INSULATION1S29 SPLICECIRCUIT_EE011S28 SPLICECIRCUIT_EE021S27 SPLICECIRCUIT_6601S26 SPLICECIRCUIT_6601S25 SPLICECIRCUIT_6601S22 SPLICECIRCUIT_6601S21 SPLICECIRCUIT_6621S20 SPLICECIRCUIT_6611S5 SPLICECIRCUIT_EE041S4 SPLICECIRCUIT_291S3 SPLICECIRCUIT_2391S2 SPLICECIRCUIT_2391R1P20-1075 DEUTSCH.

2 _TERMINATING_RESISTOR_120-ohm1P52 P20-1158-202 GRAY_DEUTSCH_DTP_PLUG_SEALED1P51 16-06777 BLACK_DEUTSCH_DT_SEALED1P34 16-06461 BLACK_PACKARD_METRI-PACK_280_SEALED1P33 16-04464 BLACK_PACKARD_WP_TOWER_SEALED1P32 16-06461 BLACK_PACKARD_METRI-PACK_280_SEALED1P31 P20-1040 BLACK_PACKARD_METRI-PACK_150_SEALED1P18 16-06461 BLACK_PACKARD_MP_280_SEALED1P10 16-06461 BLACK_PACKARD_MP_280_SEALED1P916-06461 BLACK_PACKARD_MP_280_SEALED1P816-06414LT -GRY_PACKARD_MP_150_SEALED1P716-06414LT- GRY_PACKARD_MP_150_SEALED1P6P20-1082 BLACK_PACKARD_MP_150_SEALED1P4P20-1158-2 04 GRAY_DEUTSCH_DTP_PLUG_SEALED1P3P20-1063- 04 BLACK_DEUTSCH_DRC_PLUG_SEALED1P2P20-1133 -19-3-2 BLACK_DEUTSCH_HDP20_PLUG_SEALED1P1P20-11 33-47-5-2 BLACK_DEUTSCH_HDP20_PLUG_SEALED1J69P67-1 005-102-2 BLACK_PACKARD_METRI-PACK_150_SEALED1J601 6-06778 BLACK_DEUTSCH_DT_SEALED1J43P20-1072 BLK_DEUTSCH_DT_RECPT_SEALED_(J1939-THRU) 1J2816-06568 BLACK_PACKARD_METRI-PACK_280_SEALED1J716 -04465 BLACK_PACKARD_WP_SHROUD_SEALED1J6P20-107 2 BLK_DEUTSCH_DT_RECPT_SEALED_(J1939-THRU)

3 TERM 46 TERM 47 CABLE660-6 CONNECTORFINAL ASSEMBLYDETAIL "J"WIRE TERMINATION FOR P20-1072 DETAIL "L"J1939 DATA LINK CABLE SPLICESHRINK TUBETERM 37660-1662-1661-1TO TERMINAL T15 CABLE CABLEDETAIL "K"WIRE TERMINATION FOR P20-1063- 04660-0662-0661-0660-0662-0661-0 DATA WIRES660-3 DRAIN WIRE SPLICE TOBACKBONEHARNESSTOTERMINATINGRESISTORTO ENGINEECU660-2662-2661-2 CONNECTORFINAL ASSEMBLYPIN APIN BPIN CCABLESHIELDED25mmSEAL SHRINK TUBEWITH 3M JET MELTADHESIVE #3789660-1662-1661-1 DATA WIRES660-4 DRAIN WIRE SPLICE SEAL SHRINK TUBE WITH 3M JET MELT ADHESIVE #3789 50mm75mmCABLESHIELDED25mmSEAL SHRINK TUBEWITH 3M JET MELTADHESIVE #378950mm75mmNOTES:1) ASSEMBLE PER PETERBILT MPS ) FOR USE WITH MODEL 387 TRUCK WITH CUMMINS ISX AND SIGNATURE SERIES ENGINES, WITH CM870 ) SELECT TERMINALS PER SK28129.

4 USE TERMINAL CODE 11 OR 12 WITH THE FOLLOWING EXCEPTIONS: ITEM #/CONNECTOR/TERMINAL TERMINAL CODE/PN J43, P3, AND J6 21 T1 12-1/4 T2 AND T3 12-7/164) CIRCUITS 660-0, 661-0, 662-0, AND FOR CIRCUITS 660-1, 661-1, 662-1, AND FOR CIRCUITS 660-2, 661-2, AND 662-2, USE P92-1549 OR ) THE FOLLOWING CIRCUITS TO BE TWISTED PAIRS AND TRIPLETS (ONE TWIST PER 25MM): TWISTED PAIRS 417-1 AND 418-1 DATA LINK, J1587/J1708 EE25 AND EE26 VEHICLE SPEED TWISTED TRIPLETS EE12-1, EE22-1, AND EE23-1 THROTTLE EE02-4, EE39-1, AND EE58-1 REMOTE THROTTLE6) HARNESS MANUFACTURER TO ASSEMBLE THE FOLLOWING: CONNECTORS J7 AND P33 CONNECTORS J28 AND P18 CONNECTORS J60 AND P51 CONNECTORS J69 AND P31 CONNECTOR J43 AND TERMINATING RESISTOR R17) PLUG ALL UNUSED CAVITIES AND SEAL ALL WEATHER PROOF CONNECTORS AS FOLLOWS.

5 USE 16-07833 FOR METRI-PACK, WEATHER-PACK, AND DEUTSCH ) CONVOLUTED TUBING SHALL BE MAXIMIZED TO THE REAR OF EACH CONNECTOR WITHOUT PLACING STRAIN ON TERMINALS AS MANUFACTURING PROCESS ) PART NUMBER IS GENERATED BY THE FOLLOWING: P92-6083-ABC EXAMPLE: PN P92-6083- 021 IS FOR WITH J1939 DATA LINK , AND WITHOUT DUAL STATION ) YELLOW TAPE INDICATES HARNESS ROUTING INDEX ) THE USE OF CAVITY PLUGS ON P1, P2, AND P3 IS ) SPLICE LOCATIONS ARE SHOWN FOR REFERENCE ONLY WITH THE EXECPTION OF THE FOLLOWING: SPLICE S4 SHALL BE PLACED AS CLOSE TO CONNECTOR P2 AS IS ) FOR HARNESS MANUFACTURER USE ONLY: SIMILAR TO ) SUPERSEDES P92-6047-000SS SEE TABLE B SEE TABLE C SEE TABLE ACMATERIALPRODUCT DESCRIPTIONPART NUMBERITEMQTYPRODSVCEXX90 BACKSHELL CONVOLUTED TUBINGP20-1063-04 DETAIL "M"P20-1063- 041411050 6 1 6 4110 50 MATING VIEW 11 HARNESS- ENGINE, CUM ISX PB387P92-6083-1P9 LABEL:A/C CLUTCHCKT : COOLANT LEVELSENSORCKT :A/C PRESS SWITCHCKT : STARTERINTERRUPT JUMPERCKT :STARTER INTERRUPTCKT : STARTER TERMINALSOLENOIDCKT.

6 ENGINE GROUNDCKT : NEUTRAL STARTINTERRUPT JUMPERCKT : NEUTRALSTART INTERRUPTCKT : ENGINE GROUNDCKT : ENGINE GROUNDCKT : XMSN TEMP SENSORCKT : ENGINE FANSOLENOID VALVECKT : VEHICLESPEED SENSORCKT : REVERSECKT : ETHER SOLENOID VLVCKT : DASH ENGINE HARNESSCKT : CHASSIS LOAD CENTERCKT : DUAL STATION CONTROLSCKT : J1939 DATA LINKCKT : ENGINE ECUCKT : PRIMING PUMPCKT : J1939 DATA LINKCKT SEE CHART "A" FOR CIRCUIT CONFIGURATION ON SHEET 1. SEE DETAIL "K" FOR WIRE TERMINATION ON SHEET 1. SEE DETAIL "M" FOR CONVOLUTE TERMINATION ON SHEET STATION CONTROLS- REMOTE PTO ENABLE- REMOTE THROTTLE ENABLE- REMOTE THROTTLE CONTROL- TORQUE LIMIT SWITCHR1 TAPE BACKK344-813P33J28J69250 MARK WITH YELLOW TAPE(SEE NOTE 10) MARK WITH YELLOW TAPE (SEE NOTE 10)175 TAPE BACKJ7P31P18P3P51J60J43 SEE DETAIL "J" FOR WIRE TERMINATION, ON SHEET DETAIL "J" FOR WIRE TERMINATION, ON SHEET VIEW12 76 1 AB500150800 TAPE BACK LOCATION FOR J1939 CABLE SPLICE.

7 SEE DETAIL "L", SHEET VIEW CA B BA21 MATING VIEWAAMAIN HARNESSBUNDLEMULTI-FUNCTIONCONNECTOR BREAKOUTECM PORT"J2" AND "J3"BREAKOUTJ1939 DATA LINKBREAKOUTSECTION A-AMATING VIEW CA B 81992134567101112131415161718 MATING VIEWMATING VIEW431216344431720338374613523541918731 2934647423622452921101138254012394127142 6131530242832 MATING VIEW 4730 45 15 535 20 1 10 25 40 BAABAB100100 BAHARNESS- ENGINE, CUM ISX PB387P92-6083-2 ENGINEGROUNDETHERSOLENOIDVEHICLESPEEDSEN SORA/C PRESS SWITCH(OPEN CIRCUIT = FAN ON)A/CCLUTCHREVERSE(BU LP SW)XMSN TEMPSENSOR(GAUGE)STARTERINTERRUPT(OVERCR ANK)JUMPERENGINEECUSAE J1939 DATA LINKENGINEHARNESSTOENGINE DASHHARNESSEE24-1 , LT_GRNEE10-1 , BRN/WHTEE08-1 , BLUEE15-1 , LT_GRNEE08-1 , BLUEE15-1 , LT_GRNEE07-1 , PINKEE17-1 , YELEE07-1 , PINKEE17-1 , YELEE05-1 , LT_GRN/BLKEE06-1 , YEL/BLKEE04-1 , LT_GRN/YELEE05-1 , LT_GRN/BLKEE02-1 , BLK/WHTEE01-2 , BLK/WHTEE01-2 , BLK/WHTEE14-1 , BLUEE13-1 , RED/ORNEE13-1 , RED/ORNEE14-1 , BLUEE04-2 , LT_GRN/YELEE04-2 , LT_GRN/YELEE22-1 , PINKEE22-1 , PINKEE28-1 , GRNEE28-1 , GRN417-1 , PRP418-1 , WHT418-1 , WHT417-1 , PRPEE21-1 , REDEE21-1 , REDEE20-1 , WHTEE20-1 , WHTEE43-1.

8 WHTEE01-4 , BLK/WHTB239-1 , BLK239-6 , BLKB239-1 , BLK239-7 , BLK239-3 , BLK239-8 , BLKA269-1 , PINK/WHTA269-1 , PINK/WHT239-4 , BLK29-2 , PRP577-1 , BLK577-1 , BLK30-2 , ORN30-2 , ORNEE41-1 , WHT/LT_GRNEE41-1 , WHT/LT_GRNENGINEHARNESS93-1 , LT_GRN/WHT93-1 , LT_GRN/WHTEE26 , BLU/ORNEE25 , BLU/REDEE03-4 , BLK/WHT83-1 , ORN/WHT83-1 , ORN/WHTEE31-1 , LT_GRN/PINKCOOALNTLEVELSENSOR59-1 , VIO59-1 , VIO239-9 , BLKA239-1 , BLK239-10 , BLKA239-1 , BLKNEUTRALSTARTINTERRUPTJUMPEREE01-3 , BLK/WHTEE01-4 , BLK/WHTEE03-1 , BLK/WHTEE19-1 , WHT/LT_GRNEE19-1 , WHT/LT_GRN239-1 , BLKENG FANSOLENOID VALVE(12V=FAN OFF)

9 239-3 , BLKEE03-4 , BLK/WHTSAE J1939 DATA LINKTERMINATING RESISTORENGINEHARNESSEE03-3 , BLK/WHTSTARTERTERMINALSOLENOID661-0 , YEL662-0 , GRN660-3 , WHT661-1 , YEL661-2 , YEL662-1 , GRN662-2 , GRN660-1 , BARE660-5 , WHT660-4 , WHTEE12-1 , BLK/REDEE23-1 , GRN/BLUEE01-1 , BLK/WHTEE03-2 , BLK/WHTEE18-1 , GRN/WHTEE39-1 , GRN/YELEE63-1 , WHT/BLKEE58-1 , GRNEE02-4 , BLK/WHT660-6 , WHT660-2 , BARE660-2 , BARE662-2 , GRN661-2 , YEL660-1 , BARE662-1 , GRN661-1 , YELDUAL STATIONCONTROLSREMOTE PTO ANDTHROTTLE OPTIONSEE64-1 , LT_BLUEE03-2 , BLK/WHTEE18-1 , GRN/WHTEE64-1 , LT_BLUEE63-1 , WHT/BLKEE39-1 , GRN/YEL239-5 , BLK30-3 , ORNPRIMINGPUMPEE58-1 , GRNEE12-1 , BLK/REDEE23-1 , GRN/BLUEE02-3 , BLK/WHTEE02-2 , BLK/WHTEE31-1 , LT_GRN/PINKTHE VEHICLE SPEED SENSOR IS OMITTEDWHEN USED WITH ELECTRONIC CONTROLLEDTRANSMISSIONS THAT BROADCAST VEHICLESPEED INFORMATION OVER THE SAE J1939 DATA LINK , ORN660-0 , BARE661-0 , YEL662-0 , GRN660-0 , BARE239-2 , BLK660-6 , WHTEE03-3 , BLK/WHT239-5 , BLK29-3 , PRP29-1 , PRP29-1 , PRPSEE NOTE 12 FORSPLICE LOCATIONENGINEECUS3S4S2S25S26S28S22S21S2 0S27S5S29T151P51781141012