CARL R. DARNELL ARMY MEDICAL CENTER - Army and Air …

1 carl R. DARNELL army MEDICAL CENTER FORT HOOD, TEXAS SPECIFICATIONS March 11, 2016 2821 West 7th Street, Suite 400 Fort Worth, TX 76107 Office 817-877-5571 Fax 817-877-4245 Multatech Project No. carl R. Darnall army MEDICAL Center3/11/2016 Fort Hood, TexasTABLE OF CONTENTS - 1 TABLE OF CONTENTSDIVISION 00 - PROCUREMENT AND CONTRACTINGREQUIREMENTS00 01 07 SEALS PAGEDIVISION 01 - GENERAL REQUIREMENTS01 10 00 SUMMARY OF WORK01 10 17 AAFES FURNISHED AND INSTALLED EQUIPMENT01 10 18 AAFES FURNISHED CONTRACTOR INSTALLED EQUIPMENT01 10 60 SAFETY POLICIES AND PROCEDURES01 10 61 SAMPLE SAFETY PLAN01 10 62 SAMPLE CONSTRUCTION HAZARD PLAN01 31 13 PROJECT MANAGEMENT & COORDINATION01 30 10 SUBMITTALS AND RFI'S01 40 00 QUALITY REQUIREMENTS01 77 00 CLOSEOUT PROCEDURES01 78 10 PROJECT RECORD DOCUMENTS01 78 20 OPERATION AND MAINTENANCE DATADIVISION 03 - CONCRETE03 30 00 CAST-IN-PLACE CONCRETE03 35 36 POLISHED CONCRETE FLOOR FINISHDIVISION 05.

2 METALS05 50 00 METAL FABRICATIONSDIVISION 06 - WOOD, PLASTICS, AND COMPOSITES06 10 00 ROUGH CARPENTRYDIVISION 07 - THERMAL AND MOISTURE PROTECTION07 84 00 FIRESTOPPING07 90 05 JOINT SEALERSDIVISION 08 - OPENINGS08 11 13 HOLLOW METAL FRAMES08 14 16 FLUSH WOOD DOORS08 31 00 ACCESS DOORS AND PANELS08 38 10 DOUBLE ACTING IMPACT TRAFFIC DOOR08 43 13 ALUMINUM-FRAMED STOREFRONTS08 71 00 DOOR HARDWARE08 80 00 GLAZING08 91 00 LOUVERSDIVISION 09 - FINISHES09 21 16 GYPSUM BOARD carl R. Darnall army MEDICAL Center3/11/2016 Fort Hood, TexasTABLE OF CONTENTS - 209 22 16 NON-STRUCTURAL METAL FRAMING09 30 00 TILING09 51 00 SUSPENDED ACOUSTICAL CEILINGS09 65 00 RESILIENT FLOORING/BASE09 90 00 PAINTING AND COATING09 93 00 STAINING AND TRANSPARENT FINISHING09 97 10 FIBERGLASS REINFORCED PANELSDIVISION 10 - SPECIALTIES10 14 00 SIGNAGE10 26 01 WALL AND CORNER GUARDS10 44 00 FIRE PROTECTION SPECIALTIESDIVISION 22 - PLUMBING22 05 16 EXPANSION FITTINGS AND LOOPS FOR PLUMBING PIPING22 05 53 IDENTIFICATION FOR PLUMBING PIPING AND EQUIPMENT22 07 16 PLUMBING EQUIPMENT INSULATION22 07 19 PLUMBING PIPING INSULATION22 10 05 PLUMBING PIPING22 10 06 PLUMBING PIPING SPECIALTIES22 30 00 PLUMBING EQUIPMENT22 40 00 PLUMBING

3 FIXTURESDIVISION 23 - HEATING, VENTILATING, ANDAIR-CONDITIONING (HVAC)23 05 53 IDENTIFICATION FOR HVAC PIPING AND EQUIPMENT23 05 93 TESTING, ADJUSTING, AND BALANCING FOR HVAC23 07 13 DUCT INSULATION23 09 13 INSTRUMENTATION AND CONTROL DEVICES FOR HVAC23 31 00 HVAC DUCTS AND CASINGS23 33 00 AIR DUCT ACCESSORIES23 37 00 AIR OUTLETS AND INLETSDIVISION 26 - ELECTRICAL26 05 19 BUILDING WIRE AND CABLE26 05 26 GROUNDING AND BONDING FOR ELECTRICAL SYSTEMS26 05 29 HANGERS AND SUPPORTS FOR ELECTRICAL SYSTEMS26 05 34 CONDUIT26 05 37 BOXES26 05 53 IDENTIFICATION FOR ELECTRICAL SYSTEMS26 09 23 LIGHTING CONTROL DEVICES26 24 16 PANELBOARDS26 27 26 WIRING DEVICES26 51 00 INTERIOR carl R. Darnall army MEDICAL Center3/11/2016 Fort Hood, Texas00 01 07 - 1 SEALS PAGESEALS PAGEARCHITECTUREELECTRICALMECHANICAL AND PLUMBINGEND OF carl R.

4 Darnall army MEDICAL Center3/11/2016 Fort Hood, Texas00 01 07 - 2 SEALS carl R. Darnall army MEDICAL Center3/11/2016 Fort Hood, Texas01 10 00 - 1 SUMMARY OF WORKSUMMARY OF WORKPART OF : The work covered by these specifications consists of furnishing all supervision, labor,equipment and materials required to construct a new Express convenience store and BarberShop within the newly operational carl R. Darnall army MEDICAL CENTER , in accordance withthese specifications and the applicable drawings, and subject to the terms and conditions of : The work to be performed is located in the new carl R. Darnall army MEDICAL Centerlocated on Santa Fe Avenue in Fort Hood, to be provided at Marvin Leath Visitor CENTER on Mills Blvd off from of construction of door and of wall new facility :1)Sales )Managers )Backroom Storage Shop.

5 1)Barber ) of all related Plumbing, HVAC and Electrical work commensurate with theProject alarm and mass notification , heating ventilating and air rough-ins, data and sound copy of the General Provisions of the Contract is included in the Solicitation are advised to take note of the and structures on and surrounding and and storage responsibilities indicated in General INSTALLATION working hours on Post are from 0700 to 01600 hours. streets will be blocked without Post DPW shall immediately clean up any debris tracked on to streets resulting from thisconstruction areas, including equipment, temporary office and storage areas, shall be keptclean and carl R.

6 Darnall army MEDICAL Center3/11/2016 Fort Hood, Texas01 10 00 - 2 SUMMARY OF burning is permitted on the (WATER, SEWER, GAS AND ELECTRICITY) will be required to coordinate with the Health Facility Planning Agency (HFPA) tolocate connection points to existing utilies. (water, sewer, gas and electricity). OUT and elevations indicated in layout of work shall be verified between Drawings, specifications, and Conditions shall be referred to theContracting Officer in writing for adjustment before work affected is to make such notifications shall place responsibility upon Contractor to carry outwork in a satisfactory and workmanlike shall be responsible for the location and elevation of all the constructioncontemplated by the construction to commencing work, Contractor shall carefully compare and check allArchitectural, Mechanical, Plumbing and Electrical drawings, each with the other.

7 That in anyway affect the locations of elevation of the work to be executed by discrepancy shall be immediately reported to the Contracting Officer ordesignated representative for verifications and duplication of work made necessary by failure or neglect on Contractor's part tocomply with this function shall be done at his drawings accompanying these specifications indicate the general design andarrangement of all apparatus, fixtures and accessories necessary to complete the location or arrangement of equipment may be subject to minor changesnecessitated by field conditions and shall be made as required without additional cost shall be verified by actual observations at the construction site, andContractor shall be responsible for all work fitting into place in a satisfactory andworkmanlike manner meeting the approval of the Contracting OVERHEAD OR UNDERFLOOR check the site where project is to be erected and observe any overhead wires such work shall be moved, replaced, or protected, as required.

8 Whether or not shownor is directed to the existence of pipe and other underfloor improvements that are shownon the reasonable precautions shall be taken to preserve and protect all suchimprovements shown on the drawings and not scheduled for OF EXISTING UTILITIES shall make utility connections Hot/Live whenever Hot/Live connections are not feasible, Contractor shall perform the work under thisContract with a minimum of outage time for all may be required to perform the work while the existing utility is in shall be by written approval from utility utility services may only be interrupted when approved, in writing, by theContracting Officer and Ft. Hood DPW and carl R.

9 Darnall army MEDICAL Center3/11/2016 Fort Hood, Texas01 10 00 - 3 SUMMARY OF it is necessary to interrupt the existing utilities, Contractor shall notify theContracting Officer, Ft. Hood DPW, HFPA and utility owner in writing at least ten (10) businessdays in advance of the time he desires the existing service to be time shall be kept to a upon the activities at the facility that require continuous service from theexisting utility, an interruption may not be subject to schedule at the time desired by such cases the interruption may have to be scheduled at a time of minimumrequirement of demand for the utility including nights, weekends or amount of time requested by the Contractor for interruption of existing utilityservices shall be as approved, in writing, by the Contracting Officer, Ft.

10 Hood DPW,HFPA and utility to commencing any welding, Contractor shall obtain a welding permit through Ft. HoodDPW offices from the Ft. Hood Fire AND WARNING shall provide barricades and lighting devices, in accordance with Manual for UniformTraffic Control Devices by Department of Transportation, latest Edition, at all points ofexcavation and construction in vehicle traffic FOR OPEN FLAME open flame and/or spark producing devices, , acetylene oxygen weldingequipment, electric arc welding, sweat soldering, etc., are employed for job accomplishment,the following procedures are all surroundings and equipment to insure that combustible substances are notpresent in any area where contact of metal at a temperature above the flashpoint of anycompound is that no open containers or spills of combustible substances are that ignition is not possible by conduction, convection, radiation, ordispersion of molten protection equipment and practices will be used, , fireproof blankets, wetting ofsurrounding area, removal o combustible materials where practicable.