FLUID CAPACITY CHART - VW Parts

1 FLUID CAPACITY CHART . A/C. REFRIGERANT. ENGINE OIL AUTO COOLING SYS- POWER REFRIGERANT. MANUAL TRANS. AUTO TRANS. R-12. (Rev 11/04) DIFF. TEM STEERING OIL. R134a 01V T (AEB). T (AEB). Dry Fill W/AutoTrans. w/filter 01V. 9 0L ( ). (9 5 t) 6 2L ( ). (6 5 t). ( ) G052145A2. Changing W/Std. Trans. G002 000. See * below 75W90. PASSAT 012 ( ) ( ) 250cc Dry fill 650 + 50 grams 1998/1999 (AHA) ( ) 01N ( ) ( oz). ( ) (23 + oz). w/filter Dryy fill DO NOT USE ATF. ffilled for f life, f no 2 8L (AHA). ( ) ( ). change ( ). ( ) g g Changing Diesel N/A ( ). (AEG). w/filter /filt G052145A2. 01M. ( ) 02J trans. 75W90 (AEG).

2 G052162A2 G002 000. New Beetle (AEB) G 052 726 A2 Dry fill ( ). Dry fill -- 700 + 50 grams 135cc 1998/1999 W/filter SAE 75W90 0 75L ( ). (0 8qt). ( qt) ( ) ( + oz) ( oz). ( ) Mineral oil filled for life, no Changing (23--30oz). ( ) change h (ALH) ( qt) ((ALH)). w/filter ( ). ( ). Use API SERVICE SJ for gas eng, API SERVICE CF4 or CG4 for Diesel prevent overfilling at oil changes, add approx. 1/2qt less than CAPACITY , start engine, let run until engine operating temperature is appros. 60_C (140_ F), switch ignition OFF, wait approx. 3 minutes, check dipstick, fill to full mark as indicated on dipstick (may be more or less than 1/2qt depending on model).

3 Turbo engines only:After changing eng oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev eng! This could cause damage/ failure of turbocharger. Full oil pressure is not built up until warning light has gone out. Only then can engine be revved. * (AEB)MUST use oil meeting VW502 00 standard ONLY(either 0W40,5W40 or 5W30), and oil filter Part No 068 115 561B. See TB in group 17. COOLANT:Use only phosphate free coolant ZVW237 105 (G11) upto vehicle use ZVW237(G12) DON'T INTERCHANGE/MIX G11. & G12. Note: Part numbers are for reference only. Always check with your Parts Dept.

4 For the latest Parts information. 1 of 2. E 1999 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

5 FLUID CAPACITY CHART . A/C. REFRIGERANT. ENGINE OIL MANUAL TRANS. AUTO COOLING SYS- POWER REFRIGERANT. AUTO TRANS. R-12. (Rev 11/04) (Rev 11/04) DIFF. TEM STEERING OIL. R134a 02A/02J Trans. (ALH). ( ). w/filter G 052 726 A2. ( ). Mineral oil 01M (ALH). SAE 75W90 G052145A2. JETTA Dry Fill ( ) 135cc 15cc (AEG) Dry fill GOLF ( ) (AEG) ( ) 750 50 grams ( oz). w/filter 020 Trans. ( ). CABRIO Refill ( ) (23--30 oz) (26 oz) Use PAG oil with R. ( ) ( ) G50 Filled for life no 1998/1999 ( ) (AFP) DO NOT USE ATF 134a synthetic oil change VWATF ( ). (AFP) SAE 75W90. G052 162 A2. w/filter ( ). (AES) One evap. 02B Trans.

6 One evap. 135cc 01P Trans. G052145A2 1 heat/exch. ( ) G50 950 + 50 grams ( oz). (AES) Dry fill ( ) ( ). synthetic oil ( + oz) Two evap. EUROVAN 2 heat/exch. w/filter ( ) ( ) G 002 000. 1998/1999 SAE 75W90 ( ) Two evap. 240 cc ( ) Oil change Filled for life no ( oz). 02G Trans. 1350 +50 grams ( ) change 2 water ( ) heater ( + ) Use PAG oil ( ) with R 134a Use API SERVICE SJ for gas SERVICE CF4 or CG4 for Diesel eng. To prevent overfilling, add approx 1/2qt less than CAPACITY , start eng, run till operating temp is (140degF),switch off ignition, wait approx 3 oil level, fill to max mark(may be more/less than 1/2qt depending on model.)

7 Turbo engines only: After changing eng oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev eng! This could cause damage/failure of turbocharger. Full oil pressure is not built up until warning light has gone out. Only then can engine be revved. COOLANT: Use only phosphate free coolant ZVW 237 105 (G11) upto vehicle production date of from use ZVW 237 (G12) DO NOT. INTERCHANGE OR MIX G11 & G12. Note: Part numbers are for reference only. Always check with your Parts Dept. for the latest Parts information. 2 of 2. E 1999 Volkswagen of America, Inc. All rights reserved.

8 Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.