Water Cooled Packaged Unit - Daikin

1 Catalogue/Engineering DataWater Cooled Packaged Unit Cooling only: UCCP35AE~205AE Cooling Capacity: 32KW~199KW Cooling and Heating: UCCP35 ADE~165 ADE Cooling Capacity: 32KW~154KW Heating Capacity: 12KW~60 KWED-UCCP-201501R 407C 1 Note: Installation and maintenance are to be performed only by qualifiedpersonnel who are familiar with local codes and regulations, and experienced with this type of : Sharp edges and coil surfaces are a potential injury hazard. Avoid contact with : Moving machinery and electrical power hazard may cause severe personal injury or death. Disconnect and lock off power before servicing ..3 Dimensions ..10 Operating Limit ..15 Sound Data ..16 Fan Curves ..17 Performance Table ..19 Wiring Diagrams ..20 Installation ..28 Operation ..34 Literature No.: ED-UCCP-201501 Supersedes: ED-UCCP-201404A2 NomenclatureFeaturesThe Daikin "SCROLL" UCCP Water - Cooled Packaged units are designed for duct type air-conditioning system in commercial and industrial application.

2 The UCCP Water - Cooled Packaged unit has single or multiple hermetic compressors with independent refrigerant circuits. Each refrigerant circuit consists of a high efficiency condenser, a sealed strainer and capillary tubes. Every Daikin UCCP unit has been leak tested, evacuated and fully charged with refrigerant R407C at the Efficiency Hermetic Scroll Compressor Quiet operation. Excellent reliability with 70% fewer moving parts than comparably sized reciprocating compressors. Greater capability at handling liquid and debris in the system. High efficiency Copper Tubes CondenserExtra-high efficiency is attained by special designed shell-and-tube condenser with "T" groove copper tube surfaces for superior refrigerant- Water heat Unit CasingUnit casing is constructed of electro-galvanized steel sheet. Casing surface is finished with epoxy polyester powder coating. Therefore, units are suitable for both commercial and industrial Quiet OperationEach unit is divided into separate compartments such that compressor noise is kept away from the supply air insulation of 1/2 inch thick fiber glass and double blowers design further reduce noise AssuranceEach unit is leak-tested, evacuated, fully charged with refrigerant and run tested in Daikin s ISO9001 certified 35 A D E - 10 - F EG EExportDescriptionPower supply: A: 220V~/50Hz F: 380-415/3N~/50 HzExternal static pressure: 10: 100Pa, 15.

3 Refrigerant R407 CWith electric heater (omitted if cooling only)Design seriesCapacityWater Cooled Packaged unit3 SpecificationsGeneral DataMODELUCCP35AE/ADEUCCP55AE/ADEUCCP70A E/ADEUCCP75AE/ADENOMINAL COOLING TOTAL POWER INPUT ( ) ( ) ( ) ( ) ( ) ( ) ELECTRIC HEATING CAPACITYkW12212736 POWER SUPPLY380-415/3N~/50 HzREFRIGERANT TYPER407 CREFRIGERANT OIL TYPEPOEAIR FLOWm3/h590081001080013600 STANDARD ESPPa100 (0)150 (0)150 (0)200 SOUND PRESSURE LEVELdB(A)65677072 UNIT DIMENSIONLENGTHmm/in1278/501722/681922/7 62000/79 WIDTHmm/in677/27736/29836/331060/42 HEIGHTmm/in1902/75 (2172/86)1921/76 (2195/86)2035/80 (2404/95)1961/77 PACKING DIMENSIONLENGTHmm/in1320/521790/701990/7 82040/80 WIDTHmm/in720/28780/31895/351110/44 HEIGHTmm/in2090/82 (2410/95)2100/83 (2410/95)2230/88 (2530/100)2150/85 UNIT NET WEIGHTkg/lb280/617 (300/660)293/646 (313/690)455/1003 (485/1067)473/1043 (503/1109)610/1344 (650/1433)632/1393 (672/1481)720/1587760/1675 CONDENSATE DRAIN PIPE CONNECTIONTYPEFEMALE + + + + 2 2 REFRIGERANT OIL + 2 NOTES:1.

4 ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOMINAL COOLING AND HEATING CAPACITY ARE BASED ON THE CONDITIONS BELOW: COOLING 27 CDB/19 CWB INDOOR AND ENTER COOLING Water TEMPERATURE 30 C, RATED Water SOUND PRESSURE LEVEL TEST METHOD: POSITION OF THE MEASUREMENT POINT IS 1m IN FRONT AND 1m BELOW THE UNIT. 4. THE NUMBERS IN THE PARENTHESES ARE APPLICABLE FOR THE UNITS WITH DataMODELUCCP85AE/ADEUCCP100AE/ADEUCCP11 5AE/ADEUCCP125AE/ADENOMINAL COOLING CAPACITYkW8295110118 RATED TOTAL POWER INPUT kW20 ELECTRIC HEATING CAPACITYkW36424848 POWER SUPPLY380-415/3N~/50 HzREFRIGERANT TYPER407 CREFRIGERANT OIL TYPEPOEAIR FLOWm3/h14500170001980022000 STANDARD ESPPa200250250250 SOUND PRESSURE LEVELdB(A)72747575 UNIT DIMENSIONLENGTHmm/in2000/792000/792220/8 72220/87 WIDTHmm/in1060/421060/421243/491243/49 HEIGHTmm/in1989/781989/782068/812068/81 PACKING DIMENSIONLENGTHmm/in2040/802040/802250/8 92250/89 WIDTHmm/in1110/441110/441290/511290/51 HEIGHTmm/in2150/852150/852240/882150/86 UNIT NET WEIGHTkg/lb800/1763840/1852930/2050960/2 1161010/22261060/23371030/22701080/2381 CONDENSATE DRAIN PIPE CONNECTIONTYPEFEMALE 2 2+ 2+ 3 3 3 REFRIGERANT OIL 2+ 3 NOTES: 1.

5 ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOMINAL COOLING AND HEATING CAPACITY ARE BASED ON THE CONDITIONS BELOW: COOLING 27 CDB/19 CWB INDOOR AND ENTER COOLING Water TEMPERATURE 30 C, RATED Water SOUND PRESSURE LEVEL TEST METHOD: POSITION OF THE MEASUREMENT POINT IS 1m IN FRONT AND 1m BELOW THE UNIT. 5 General DataMODELUCCP135AE/ADEUCCP145AE/ADEUCCP1 65AE/ADEUCCP185 AEUCCP205 AENOMINAL COOLING CAPACITYkW132144154180199 RATED TOTAL POWER INPUT kW33 ELECTRIC HEATING CAPACITYkW48606055 (External)55 (External)POWER SUPPLY380-415/3N~/50 HzREFRIGERANT TYPER407 CREFRIGERANT OIL TYPEPOEAIR FLOWm3/h2200024600264002880033000 STANDARD ESP (OPTION)Pa300(350/400/450)300(350/400/45 0)350(400/450)350(400/450/500)350(400/45 0/500)SOUND PRESSURE LEVELdB(A)7677777879 UNIT DIMENSIONLENGTHmm/in2420/952420/952420/9 52675/1053002/118 WIDTHmm/in1243/491243/491243/491243/4915 34/60 HEIGHTmm/in2068/812068/812068/812068/812 083/82 PACKING DIMENSIONLENGTHmm/in2450/962450/962450/9 62700/1063085/121 WIDTHmm/in1290/511290/511290/511290/5117 00/67 HEIGHTmm/in2240/882240/882240/882240/882 300/91 UNIT WEIGHTkg/lb1225/27001255/27671235/272212 65/27891250/27551280/28221350/29751400/3 086 CONDENSATE DRAIN PIPE CONNECTIONTYPEFEMALE 4 3+ 3+ 4 4+ 4+ 3+ 2/ 3+ OIL 3+ 3+ 4+ 5 NOTES:1.

6 ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR NOMINAL COOLING AND HEATING CAPACITY ARE BASED ON THE CONDITIONS BELOW: COOLING 27 CDB/19 CWB INDOOR AND ENTER COOLING Water TEMPERATURE 30 C, RATED Water SOUND PRESSURE LEVEL TEST METHOD: POSITION OF THE MEASUREMENT POINT IS 1m IN FRONT AND 1m BELOW THE UNIT. 6 Components DataMODELUCCP35AE/ADEUCCP55AE/ADEUCCP70A E/ADEUCCP75AE/ADECOMPRESSORTYPESCROLLQUA NTITY1222 CONDENSERTYPETUBE IN TUBESHELL AND TUBEWATER FLOWm3 DROPKPa/mH2O70 PIPE SIZEinRc1-1/4"Rc2"FANTYPELOW-NOISE DOUBLE SUCTION MULTI-BLADE CENTRIFUGAL TYPEQUANTITY1 MATERIALGlDRIVEBelt DriveDIAMETERmm/in300/12380/15460/18380/ 15 MOTORTYPESQUIRREL CAGE INDUCTIONQUANTITY1 INSULATION GRADEFPROTECTION INDEx IP54 PULLEY QUANTITY2222 EVAPORATOR COILTUBEMATERIALCOPPERFINMATERIALALUMINU MFACE AREAm2 GREY(RALF032)NOTE:ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR DataMODELUCCP85AE/ADEUCCP100AE/ADEUCCP11 5AE/ADEUCCP125AE/ADECOMPRESSORTYPESCROLL OIL TYPEPOEQUANTITY4333 CONDENSERTYPESHELL AND TUBEWATER FLOWm3 DROPKPa/mH2O29 PIPE SIZEinRc2"Rc2-1/2"FANTYPELOW -NOISE DOUBLE SUCTION MULTI-BLADE CENTRIFUGAL T YPEQUANTITY1 MATERIALGlDRIVEBelt DriveDIAMETERmm/in380/15380/15380/15380/ 15 MOTORTYPESQUIRREL CAGE INDUCTIONQUANTITY1 INSULATION GRADEFPROTECTION INDEx IP54 PULLEY QUANTITY2222 EVAPORATOR COILTUBEMATERIALCOPPERFINMATERIALALUMINU MFACE AREAm2 GREY(RALF032)NOTE.

7 ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR DataMODELUCCP135AE/ADEUCCP145AE/ADEUCCP1 65AE/ADEUCCP185 AEUCCP205 AECOMPRESSORTYPESCROLLOIL TYPEPOEQUANTITY44455 CONDENSERTYPESHELL AND TUBEWATER FLOWm3 DROPKPa/mH2O29 PIPE SIZEinRc2-1/2"Rc3"FANTYPEDOUBLE INLET CENTRIFUGALQUANTITY12 MATERIALGlDRIVEBelt DriveDIAMETERmm/in380/15460/18460/18460/ 18460/18 MOTORTYPESQUORREL CAGE INDUCTIONQUANTITY12 INSULATION GRADEFPROTECTION INDEx IP54 PULLEYQUANTITY22224 EVAPORATOR COILTUBEMATERIALCOPPERFINMATERIALALUMINU MFACE AREAm2 GREY(RALF032)NOTE: ALL SPECIFICATIONS ARE SUBJECTED TO CHANGE BY THE MANUFACTURER WITHOUT PRIOR ParameterMODELM inimum cross-sectionalarea of power cord (mm )Rated Running CurrentMax. Running CurrentLive Wire (R/S/T)Neutral WireEarth Wire(A)(A) ( ) ( ) ( ) ( ) ( ) ( ) cross-sectionalarea of power cord (mm )Rated Running Current (Cooling/Heating)Max. RunningCurrentLive Wire (R/S/T)Neutral WireEarth Wire(A)(A) ( ) ( ) ( ) : 1. THE PARAMETERS IN THE PARENTHESES ARE APPLICABLE FOR THE UNITS WITH PLENUM DevicesMODELMWCP35AE/ADE~55AE/ADEMWCP70A E/ADE~205AE/ADEHIGH PRESSURE SWITCH TYPEAUTO RESET PRESSURE SWITCH TYPEAUTO RESET PROTECTION TYPEPHASE SEQUENCERELETRIC HEATER PROTECTIONTYPEAIR PRESSURE DIFFERENCE SWITCH (20Pa)TEMPERATURE THERMOSTAT PROTECTIONFUSE PROTECTIONNOTE:ELECTRONIC HEATING PROTECTION IS ONLY AVAILABLE FOR UNIT WITH ELECTRONIC HEATERD imensionsMODEL: UCCP35AE/ADED imensions in mm11 MODEL: UCCP55AE/ADED imensions in mmWATER OUTLET Rc2 Water INLET Rc2 CABLE ENTER 2"EMERGENCY DRAIN Rc1 CONDENASATE RRAIN R1 PLENUMMODEL: UCCP70AE/ADED imensions in mm 12 MODEL: UCCP75AE/ADE UCCP85AE/ADE UCCP100AE/ADED imensions in mmRemarks: MWCP75AE/ADE, MWCP85AE/ADE coupled with two pressure gauge, AWCP100AE/ADE coupled with three pressure : UCCP115AE/ADE UCCP125AE/ADED imensions in mm13 MODEL: UCCP135AE/ADED imensions in mmMODEL: UCCP145AE/ADE UCCP165AE/ADED imensions in mm14 MODEL.

8 UCCP185 AEDimensions in mmMODEL: UCCP205 AEDimensions in mm15 Operating Limit 16 27 32403016 Water Entering Temp ( C)Indoor Temp. ( CDB)STD16 Sound DataSOUND PRESSURE LEVELOUTDOOR UNITS1/1 OCTAVE SOUND PRSEEURE LEVEL (dB,ref 20 Pa)Overall (dB(A))63Hz125Hz250Hz500Hz1000Hz2000Hz40 00Hz8000 HzUCCP35 UCCP55 UCCP70 UCCP75 UCCP85 UCCP100 UCCP115 UCCP125 UCCP135 UCCP145 UCCP165 NOTES:1. RED FRAME REPRESENTS THE THE TEST METHODS: POSITION OF THE MEASUREMENT POINT IS 1m IN FRONT AND 1m BELOW THE microphonemicrophoneH(H+1)/2 Measuring Location17 Fan Curves MODEL: UCCP35AE/ADE20. 20. 20. 040. 0390100200120. 60. 55120. 060. 10. 080. 155550010001000490. 30. 40. 80. 6116120010560102020576570756007008001010 0090011001214425157625953631.

9 5808523221600140013001500182019001800170 0241. 2 kg/ m3I nner Power Ni no( kW)SOUND PRESSURE LEVEL[ dB( A) ]V OL U MEDYNAMI C PRESSUREOUT L E T V E L OC I T YC ( m/ s )CI RCUAR SPEEDU 2 ( m/ s )SPEEDn ( r / mi n )Gas densi t yPd ( 10 Pa)Q ( 1000 m / h)3 TOTAL EFFI CI ENCY ( %) MODEL: UCCP55AE/ADE/75AE/ADE/85AE/ADE/100AE/ADE /115AE/ADE/ 125AE/ADE/135AE/ADE (UCCP75AE/ADE/85AE/ADE/100AE/ADE/115AE/A DE/125AE/ADE/135AE/ADE use Double Blowers)20. 20. 20. 040. 0390100200120. 60. 55120. 060. 10. 080. 155550010001000490. 30. 40. 80. 6116120010560102020576570756007008001010 0090011001214425157625953631. 5808523221600140013001500182019001800170 0241. 2 kg/ m3I nner Power Ni no( kW)SOUND PRESSURE LEVEL[ dB( A) ]V OL U MEDYNAMI C PRESSUREOUT L E T V E L OC I T YC ( m/ s )CI RCUAR SPEEDU 2 ( m/ s )SPEEDn ( r / mi n )Gas densi t yPd ( 10 Pa)Q ( 1000 m / h)3 TOTAL EFFI CI ENCY ( %)18 MODEL: UCCP70AE/145AE/165AE/185AE/205AE (UCCP145AE/165AE/185AE/205AE use Double Blowers) 1.

10 2 kg/ m600. 260100200220. 515520. 150. 30. 20. 450555008000. 8I NNER POWER N ( kW)0. 611. 52Ga s d e n s i t y5085Q ( 1000 m / h)Pd ( 10 Pa)C ( m/ s )20651051010202050307075 SOUND PRESSURE LEVEL LA[ dB( A) ]803003340081050060012146439086735664695 946CI RCUL AR S P E E D U2 ( m/ s )900700800181620 SPEED n ( r / mi n)100022 TOTAL EFFICIENCY (%)19 Performance TableMODELAIR ON EVAPORATORLWT21 C35 C40 CNOMINAL AIR FLOW (m /h)DB TEMP ( C)WB TEMP ( C)TOTAL CAPACITY (kW)INPUT (kW)TOTAL CAPACITY (kW)INPUT (kW)TOTAL CAPACITY (kW)INPUT (kW) 20 Wiring Diagrams MODEL: UCCP35AE MODEL.