installation & operating Manual

1 3-90-00674R29_03/14 Save theSe & operating ManualModel(s):Accentra Pellet InsertNOTICE: SAVE THESE INSTRUCTIONShot glass will cause burns. Do not touch glass until it is cooled NEVER allow children to touch glass Keep children away CAREFULLY SUPERVISE children in same room as stove. Alert children and adults to hazards of high temperatures. high temperatures may ignite clothing or other flammable materials. Keep clothing, furniture, draperies and other flammable materials SurFaceS!Glass and other surfaces are hot during operation and cool !To obtain a French translation of this Manual , please contact your dealer or visit obtenir une traduction fran aise de ce manuel, s il vous pla t contacter votre revendeur ou visitez noticePleaSe read thiS entire Manual beFore You inStall and uSe Your new rooM heater.

2 Failure to Follow inStructionS MaY reSult in ProPertY daMage, bodilY injurY, or even uSe in the and canada. Suitable For installation in Mobile hoMeSiF thiS aPPliance iS not ProPerlY inStalled, a houSe Fire MaY reSult. For Your SaFetY, Follow installation directionS. do not uSe MakeShiFt coMProMiSeS. contact local building or Fire oFFicialS about reStrictionS and installation inSPection reQuireMentS in Your Your local authoritY (Such aS MuniciPal building dePartMent, Fire dePartMent, Fire Prevention bureau, etc.) to deterMine the need For a guide d'utiliSation eSt diSPonible en FrancaiS. chez votre conceSSionnaire de Fireplace insert may be installed into a masonry fireplace, an approved manufactured wood burning fireplace (see page 25), or, it may be built in to a wall or mantle system when using the optional zero clearance cabinet (see page 26).

3 Contact your local dealer with questions on installation , operation or andlisted by Portlandoregon uSaTest r alis s par OMNI-Test Laboratories, #/Rapport #135-S-12-2, 135-S-12b-6 Tested to/Test : ASTM E1509-04, ULC/ORD-C1482-M1990, ULC-S628-93 This pellet burning appliance has been tested and listed for use in Manufactured Homes in accordance with OAR 814-23-900 through 814-23-909 Normes Europ ennes:NF EN 14785 CETIAT D c. 2006 AEMC MESURES EN 50366 D c. 2006 EMITECH, APAVE & BFP Electronique F vrier 2004EN 55014-1, EN 55014-2, EN 61000-3-2, EN 61000-3-3 PREVENTION DES INCENDIESR especter scrupuleusement les instructions du constructeur pour l installation et les consignes de fonctionnement.

4 Respecter les r gles de s curit en vigueur dans votre r POUR MOBILE HOMES : Ne pas installer dans une chambre. Il est imp ratif de pr voir une prise d air ext rieur. L int grit structurale du plancher, du plafond et des murs doit tre strictement pr serv e. Se reporter aux instructions du fabricant et aux r glementations sp cifi ques locales concernant les pr cautions requises lors de la travers e d un mur ou d un plafond. Contr ler et nettoyer fr quemment tout le syst me d vacuation des fum es conform ment aux recommandations du aliser l vacuation des fum es en utilisant des conduits Sp cial granul s de 125 mm ou de la gaine fl exible inox double peau 125 mm l aide d un adaptateur ad quat comme indiqu dans la notice d pas raccorder ce po le un conduit de chemin e d j utilis pour un autre EXCLUSIVEMENT AVEC DES GRANULES DE maximum : 2,27 kg/hCaract ristiques lectriques :240 VAC 50 Hz Intensit au d marrage 2,0 A Intensit fonctionnement normal 1,1 ATenir le cordon d alimentation l cart du po : Risque d lectrocution.

5 D brancher l appareil avant toute une information plus compl te, se reporter la notice d remplacer la vitre qu avec une vitre c ramique 5 mm de m me qualit disponible aupr s de votre la porte frontale et le couvercle de tr mie herm tiquement clos durant le fonctionnement de l calorifi que mise: Nominale: 10,5 KW R duite: 1,8 KW Concentration CO ( 13 % O2) puissance nominale: < 0,02 % puissance r duite: < 0,04 %Rendement: puissance nominale: 84 % puissance r duite: 73%DO NOT REMOVE THIS LABEL/NE PAS ENLEVER CETTE TIQUETTEMADE IN THE USA /FABRIQU AUX USAMod le : ACCENTRA INSERTA ppareil de chauffage granul s de bois Prevent House Fires Install and use only in accordance with the manufacturer s installa-tion and operation instructions.

6 Contact local building or fi re offi cials about restrictions and inspection in your : FOR MANUFACTURED HOMES: Do not install appli-ance in a sleeping room. An outside combustion air inlet must be provided. The structural integrity of the manufactured home fl oor, ceiling and walls must be to manufacturer s instructions and local codes for precautions required for passing chimney through a combustible wall or and clean exhaust venting system frequently in accordance with manufacturer s a 3 or 4 diameter type L or PL venting system, or 4 stain-less steel fl ex as per owner s not connect this unit to a chimney fl ue servicing another USE WITH PELLETIZED WOOD FUEL OR UP TO A 50% CORN AND PELLET MIXTURE Rating Max: 5 lb.

7 Rating: 240 VAC, 50 Hz, Start AMPS, Run AMPSUS Electrical Rating: 115 VAC, 60 Hz, Start AMPS, Run AMPSUS Environmental Protection AgencyThis model is exempt from EPA Certifi cation under 40 CFR defi nition (wood heater(A) Air-to-Fuel Ratio )Agence Am ricaine pour la Protection de l EnvironnementCe mod le est dispens par EPA certifi cation d apr s40 CFR par d fi nition [ Appareil bois (A) Ratio air/combustible ]12 (305mm) Mantel/Manteau de Chemin eSidewall/Mur de C t Trim/Panneau de MoulureEmission of CO in Combustion: Nominal Heat Output: <.02%, Reduced Heat Output: <.04%Flue Gas Temperature: 224 CThermal Output: Effi ciency: Nominal: 84%, Reduced: 73% Route power cord away from CLEARANCES TO COMBUSTIBLE MATERIALNon-combustible fl oor protector must extend 6 (152 mm) to the sides and front of the unit, measured from the glass face (US).

8 ECARTS MINIMUM DE S CURIT La protection de sol doit tre constitu e de mat riau incombustible et s tendre de 457 mm (18 ) l avant et 203 mm (8 ) sur les c t s (CANADA). 352 Mountain House RoadHalifax PA 17032 ( USA) 3-90-00676 IGNa. insert body to side wall - 10 (254 mm)b. insert body to 12 (305mm) Mantel/ Manteau de chemin e - 12 (305 mm)C. Insert Body to combustible trim above - 3/4 (19 mm)d. insert body to side trim - 6 (152 mm)E. Floor protection. Measured from glass. - 6 ( ) -OR 8 (203mm) to sides and 18 (457mm) in front (CANADA)DANGER: Risk of electrical shock. Disconnect power supply before further instruction refer to owner s glass only with 5mm ceramic available from your viewing and ash removal doors tightly closed during LABEL008 Serial de s rie:Rev DDate of Manufacture / Date de fabrication2013 2014 2015 jan Feb Mar aPr MaY jun jul aug SeP oct nov decManufactured by/Fabriqu par.

9 Hearth and Home Technologies11 SaMPle33-90-00674r29_03/14introductionhe arth & home technologies352 Mountain House RoadHalifax, PA of Contentsautomatic operation 4 Manual operation 6eSP control 8 Assembly & installation 9venting 21 Maintenance 28trouble-Shooting 33 Specifications 34wiring diagram 35warranty 36 Service Parts List 38 Power Failures / back-up 44 Fuel Specifications 45corn / Pellet Mixture 46 The Accentra Pellet Insert will give you more heat.

10 Better temperature control and a level of convenience you won t find in any other pellet burning insert. The Accentra Insert s many outstanding features make it the best value pellet insert on the market Accentra s versatile design lets you convert a heat wasting fireplace into an efficient heating source. The Accentra Insert could also be a fireplace hearth for your home that doesn t require a chimney. A special zero clearance fireplace kit converts the Accentra insert into a fireplace that can be placed in virtually any corner or against any wall of your home. The Accentra s on-board microprocessor constantly senses room temperature and automatically makes adjustments in the feed rate and air supply so you get just the right amount of heat 24 hours a day.