Dulux Quit Rust Galvanised Iron Primer Plus …

1 WaterAir SprayAirless SprayBrushRollerNZDD1174 Dulux quit rust Galvanised iron Primer PlusPart A663-97277 ApprovalsEnvironmental Choice quit rust Galvanised iron Primer plus is a water based Primer which provides excellent adhesion and corrosion resistance for all types of new orweathered Galvanised and zinc coated surfaces. It is also suitable for all other metals surfaces including steel/wrought basedExcellent adhesion" plus " FeatureBenefitsEase of application, quick drying, clean up with need for chemical pretreatment or prolonged also be used over steel/wrought ironUsesDULUX quit rust Galvanised iron Primer plus can be applied to all cleaned Galvanised iron and zinc coated surfaces prior to coating with Dulux enamels oracrylic GuideWeatherExcellent weather resistance as part of resistance to usual exterior exposed resistance to rain and condensation for prolongedperiods as part of to aromatic hydrocarbons and alcohols.

2 Excellentwhen PropertiesThinnerWaterColourLight GreyComponents1 ToxicityLead free. Dry film is Level48 g/lTouch Dry20 MinutesClean UpClean UpDescriptionClean all equipment with waterApplicationMethodApplicationConditi onsSolids By Volume37 MinMaxRecommendedWet Film Per Coat (microns)68 Dry Film Per Coat (microns)25 Recoat Time (min)2 HoursTheoretical Spread Rate (m2/L) of Dulux datasheet nzdd1174 approved on Wednesday, 16 May 2012 9:09:18 PM (UTC)Page 1 of 3 Application GuideSurfacePreparationNOTE : Where possible, care should be taken to avoid damaging the protective Galvanised film. Following surface preparation the cleanedand dry surface should be primed as soon as SURFACESC heck the adhesion of the old paint by cutting an 'X' through the film with a razor blade or trimming knife, pressing cellulose tape firmlyacross the cut and ripping it off.

3 If the old paint comes off with the tape it should all be removed. Ensure any loose and flaking paint isscraped off. Sand all surfaces to a flat finish. Dust off. Galvanised IRONC lean with Scotch Brite and sugar soap solution. Rinse off thoroughly. Galvanised iron (aged)Remove white rust by wire brushing or scraping. Clean with sugar soap solution. Rinse off thoroughly. ZINCALUMEWipe clean with a damp rag. ZINCALUME (aged)Remove white rust by wire brushing or scraping. Clean with sugar soap solution. Rinse off thoroughly. DURAGALWipe clean with a damp rag. DURAGAL (aged)Remove white rust by wire brushing or scraping. Clean with sugar soap solution. Rinse off thoroughly. STEEL/WROUGHT IRONR emove any rust scale by scaping, sanding or wire brushing. Wipe surface with min. turps to remove residual rust , grease, oil and dirt. STEEL/WROUGHT iron (heavily rusted) : Remove rust scale by scaping, sanding or wire brushing.

4 Wipe surface with min. turps toremove residual rust , grease, oil and dirt. Treat any remaining residual rust with Dulux quit rust rust with Scotch Brite and sugar soap solution. Rinse off , roller, conventional and airless sprayStir contents thoroughly before and during use with a broad, flat stirrer using an upward lifting : Apply full even coats to the prepared Spray: Suitable for application by conventional or airless spray equipment. If necessary thin with up to 50ml/litre : Thinning can reduce the rust inhibiting performance of Dulux quit rust Galvanised iron Primer And SafetyMSDSN umber20426 UsingSafetyPrecautionsFor detailed information refer to the product label and thecurrent Material Safety Data Sheet available through DuluxSales and Customer Service to the eye may cause eye irritation. Whenspraying, inhalation of mists may produce eye protection and when spraying wear a dust maskDisposalDo not contaminate stormwater with product or product washings.

5 Do not pour product down the drain. Unwanted product should bebrushed out on newspaper, allowed to dry and then disposed of via domestic waste collection. Empty containers should be left open in a wellventilated area to dry out. When dry, recycle the container via recycling programmes. Disposal of empty paint containers via recyclingprogrammes may differ between local authorities. Check with your local council the case of emergency, please call 0800 734 607 Version of Dulux datasheet nzdd1174 approved on Wednesday, 16 May 2012 9:09:18 PM (UTC)Page 2 of 3 Transport And StoragePack A663-97277 ShipmentNameNot dangerous goods.; No special transport PointNAUNN umberNADangerousGoodsClassNAPackageGroup NADisclaimerDulux and Other marks followed by are registered trademarks. Marks followed by the symbol of are data provided within the Duspec system is correct at the time of publication, however it is the responsibility of those using this information to check that it is current prior tospecifying or using any of these coating.

6 Any advice, recommendation, information, assistance or service provided by any of the divisions of DuluxGroup (New Zealand) Pty Ltd or its related entities(collectively, DuluxGroup) in relation to goods manufactured by it or their use and application is given in good faith and is believed by DuluxGroup to be appropriate and , any advice, recommendation, information, assistance or service provided by DuluxGroup is provided without liability or responsibility PROVIDED THAT the foregoing shall notexclude, limit, restrict or modify the right entitlements and remedies conferred upon any person or the liabilities imposed upon DuluxGroup by any condition or warranty implied byCommonwealth, State or Territory Act or ordinance void or prohibiting such exclusion limitation or modification. Coating systems can be expected to perform as indicated on the DuspecSpec Sheet so long as applications and application procedures of the individual products are followed as recommended on the appropriate Product data Sheet.

7 "Orica" " Dulux " "Berger""Berger Gold Label" "Hadrian" "Walpamur" "Levene" "Acratex" and Other marks followed by are registered trademarks. Marks followed by the symbol are note that this document is only valid for 60 days from the date of (New Zealand) Pty Ltd 150 Hutt Park Road NZ ACN 133 404 118 Version of Dulux datasheet nzdd1174 approved on Wednesday, 16 May 2012 9:09:18 PM (UTC)Page 3 of 3